Torque Specifications
TORQUE SPECIFICATIONS
| Application | Ft. Lbs. (N.m) | |
|---|---|---|
| A/C Compressor | ||
| Front Bolts | 36 (49) | |
| Rear Bolts | 19 (25) | |
| Discharge Hose-To-Condenser Inlet | 17 (23) | |
| Receiver/Dehydrator-To-Condenser Outlet | 12 (16) | |
| Refrigerant Line/Hose Fittings | ||
| At Compressor | 18 (25) | |
| At Thermal Expansion Valve | 18 (25) | |
| Seat Bolts | 26 (35) | |
| Shifter Nut | 18 (25) | |
| Steering Column Bolts | 26 (35) | |
| INCH Lbs. (N.m) | ||
| AIR System Combination Valve Nuts | 62 (7.0) | |
| AIR System Pipe-To-Exhaust Manifold Studs | 62 (7.0) | |
| HVAC Control Head/Radio | 22 (2.5) | |
| A/C Refrigerant Pressure Sensor | 49 (5.5) | |
| Blower Motor Mounting Screws | 15 (1.7) | |
| Blower Unit Bracket-To-Cowl Bolt | 19 (2.2) | |
| Center Air Outlet Duct | 89 (10.0) | |
| Clutch Coil-To-Compressor Screws | 44 (5.0) | |
| Compressor Clutch Drive Plate-To-Compressor (Center Bolt) | 115 (13.0) | |
| Compressor Pressure Relief Valve | 62 (7.0) | |
| Condenser Bracket-To-Radiator Bolts | 53 (6.0) | |
| Cooling Fan Motor-To-Shroud Screws | 35 (4.0) | |
| Cooling Fan-To-Motor Nut | 27-44 (3.0-5.0) | |
| Front Console Screws | 22 (2.5) | |
| Ground Wire-To-"H" Brace | 19 (2.2) | |
| "H" Brace-To-Front Floor Bracket | 22 (2.5) | |
| HVAC Control Module-To-I/P Retainer | 22 (2.5) | |
| HVAC Module-To-Beam Bolts | 53 (6.0) | |
| I/P Cluster Retaining Screw | 27 (3.0) | |
| I/P End Cap Retaining Screws | 22 (2.5) | |
| I/P Retainer Assembly Fasteners | 89 (10) | |
| I/P Upper Trim Panel Fastener | 53 (6.0) | |
| Inflator Module Bolts | 89 (10) | |
| Inflator Module Cover Fasteners | 19 (2.2) | |
| Liquid Line-To-Receiver Dehydrator | 124 (14) | |
| Lower Heater Core Cover Screws | 15 (1.7) | |
| Lower Heater Duct | 15 (1.7) | |
| Radio Ground Strap-To-"H" Brace | 19 (2.2) | |
| Radio-To-I/P Retainer | 22 (2.5) | |
| Rear Console Screws | 22 (2.5) | |
| Receiver-Drier Mounting Bolt | 89 (10.0) | |
| Recirculation Motor Mounting Screws | 15 (1.7) | |
| Side Heater Core Cover Screws | 15 (1.7) | |
| Steering Column Filler Panel Fasteners | 22 (2.5) | |
| Steering Column Shroud Fasteners | 13 (1.5) | |
| Thermal Expansion Valve-To-Evaporator Bolts | 89 (10.0) | |
| Upper Transaxle Cooler Line | 120 (13.5) | |
| Windshield Defroster Nozzle | 19 (2.2) | |