Technical Service Bulletins: Other Variant
WARNING: This page is about the Vue Base, 2.2 D, AWD, which is a different variant/trim than selected.
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- New PAG Oil Released (02-01-39-004B)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- Heater-Ventilation-Air Conditioning (HVAC) Hiss-Type Noise (Replace Low Speed Engine Cooling Fan Resistor) (04-01-37-006)
- Information On Serpentine Belt Wear (04-06-01-013)
- Accessories & Equipment
- Diagnostic Tip - SPS Programming SATURN Vehicles (PIC6533)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Essential Service Tool Update # 2 (U.S. Retailers Only) (08-00-89-020)
- Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
- Essential Service Tool Update #9 (U.S. Retailers Only) (06-00-89-056)
- Accessories Control Systems
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Delayed Activation of Automatic Headlamps in Low Ambient Light Conditions (Reprogram Body Control Module [BCM]) (05-08-42-006)
- Interior Dome Lamp Will Not Turn Off When Right Front Door Is Closed or Horn Sounds Intermittently in Alarm Mode (Diagnose and Install Foam Support) (05-08-42-002A)
- Power Windows and Power Sunroof (if equipped) Inoperative (Install 30A Circuit Breaker) (05-08-64-004)
- Accessory Drive Belts
- Air Bag, SRS
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- Anti-Lock Brakes
- Anti-Theft Systems
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Information on Servicing VUE Lock Cylinder Components (05-08-64-037)
- Interior Dome Lamp Will Not Turn Off When Right Front Door Is Closed or Horn Sounds Intermittently in Alarm Mode (Diagnose and Install Foam Support) (05-08-42-002A)
- Theft Deterrent Feature Will Not Set On Cassette Single Cd Player Radio (RPO Up0) (Replace Radio) (04-08-44-013)
- Automatic Trans
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Gates G-Force CVT Belt Installation (TT004-13)
- Vibration Analysis Worksheet (03-00-91-001I)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- M16, M75 VT25E (VTi) Transaxle - Information on Damage to Input Hub Seal and/or Variable Drive Pulley Follower After Case Cover Replacement, DTCs P0741, P0742, P1882 (07-07-30-016)
- Information on Transaxle Oil Cooler Flushing Procedure for VTi (VT25E) Transaxles (03-07-30-022A)
- No Movement in Drive or Reverse with or without DTC P0741, P0742, P0841, P1756, P1758, or P1882 (Replace Case Cover Assembly and Filter) (04-07-30-024E)
- Grind/Rattle Noise from Transaxle in Park and Neutral After an Extended Cold Soak Following Case Cover Replacement or Other Internal Transaxle Overhaul (Replace Case Cover Assembly, Torque Converter and Filter) (04-07-30-032A)
- Transmission Fluid Leak from Right Hand Axle Seal Area (Replace Right Hand Axle Seal with New Design Double Dust Lip Seal) (06-07-30-001)
- No Movement in Drive or Reverse with or without DTC P0741, P0742, P0841, P1756, P1758, P1882 (Bulletin Canceled - Follow SI Diagnostic Procedures) (04-07-30-024B)
- Service Engine Soon (SES) Telltale Illuminated with Diagnostic Trouble Code (DTC) P0742 Set (Reprogram Transaxle Control Module [TCM]) (05-07-30-006)
- Intermittent No Movement in Drive or Reverse with or without Diagnostic Trouble Codes (DTCs) P0841, P1758, and/or P1882 (Replace VT25E Case Cover Assembly, Torque Converter and Oil Cooler Lines, If Necessary) (05-07-30-004)
- Quick Tips for Warranty Administration (05-00-89-007)
- Intermittent Hesitation During Vehicle Launch (Replace Transaxle Input/Output Sensors or Transaxle Case Cover Assembly, If Necessary) (05-07-30-003)
- SMU - Liquid POLYACRYLATE (Pa) Sealant Application Requirements (04-07-30-011B)
- Low Speed Grind Noise And/Or Hesitation While Driving (Install New Transmission Control Module (TCM) Calibration And Add New Transmission Fluid And Additive) (03-07-30-051A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- Revised VT25E (VTI) Spacer Plate Available (04-07-30-036)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Hiss/Chirp Noise In Park Or Neutral (Install New Transmission Control Module (TCM) Calibration) (04-07-30-005)
- No Wheel Movement In Snow Or Slippery Surfaces (Reprogram TCM) (04-07-30-007)
- Speedometer Fluctuation (Replace Input/Output Speed Sensor Assembly) (04-07-30-001)
- Service Manual Update Regarding Transmission Fluid Replacement (03-07-30-058)
- Service Information Regarding Transaxle Poor Performance After Case Cover Replacement, DTC P1882 Set (03-07-30-048)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- Service Engine Soon (SES) Lamp Illuminated With Diagnostic Trouble Code (DTC) P0496 Set And/Or Hard Start Or Extended Crank After Adding Fuel (Replace EVAP Canister Purge Solenoid Valve) (04-06-04-046)
- Axle Shafts
- Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Body Interior
- Diagnostic Tip - SPS Programming SATURN Vehicles (PIC6533)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Delayed Activation of Automatic Headlamps in Low Ambient Light Conditions (Reprogram Body Control Module [BCM]) (05-08-42-006)
- Power Windows and Power Sunroof (if equipped) Inoperative (Install 30A Circuit Breaker) (05-08-64-004)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Information On Serpentine Belt Wear (04-06-01-013)
- Communication Devices
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Information On Upgrading Certain ONSTAR® Analog/Digital-Ready Systems To ONSTAR® Generation 6 Digital-Capable System (05-48-46-006G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Servicing Vehicles Upgraded To ONSTAR® Generation 6 Digital-Capable System (Follow Information Below) (09-08-46-001)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- OnStar® Generation 5 or 6 (Digital) System Inoperative/Has No Power, LED Light Not On (Remove/Reinstall OnStar® Fuse and Replace VCIM or Follow SI Diagnostics) (05-08-46-001D)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative in Alaska Only (Cancel Corporate Bulletin Number 05-08-46-002A) (05-08-46-002B)
- Parts Restriction on Ordering OnStar(R) Generation 5 and 6 Vehicle Communication Interface Modules (VCIM) (03-08-46-004A)
- Cooling Fan
- Cooling System (Mechanical)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- Information On Serpentine Belt Wear (04-06-01-013)
- Cruise Control Systems
- Cruise Control Inoperative and/or Service Vehicle Soon (SVS) "Wrench" Telltale Illuminated with Diagnostic Trouble Code (DTC) P0571 Stored in Powertrain Control Module (PCM) (Reprogram PCM) (04-08-68-004B)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- Differentials & Drive Axles
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Moan/Grown Noise/Vibration From Rear Of Vehicle When Turning At Low Speeds (Replace Rear Drive Module Differential Clutch Drum) (03-04-20-003B)
- Vibration Felt In Seatback Or Armrest At Vehicle Speeds Between 48 To 89 Km/H (30 To 55 Mph) (04-04-17-002)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Service Manual Update For RTV Sealant Usage On The Rear Drive Module (04-04-20-002)
- Drone Noise Between 50-75MPH (80 - 120 Km/H) (Install New Rear Drive Module Rear Mount Bushing Assembly) (04-04-20-001)
- Driveshaft & Universal Joints
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- Drone Noise Between 50-75MPH (80 - 120 Km/H) (Install New Rear Drive Module Rear Mount Bushing Assembly) (04-04-20-001)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Cruise Control Inoperative and/or Service Vehicle Soon (SVS) "Wrench" Telltale Illuminated with Diagnostic Trouble Code (DTC) P0571 Stored in Powertrain Control Module (PCM) (Reprogram PCM) (04-08-68-004B)
- Service Engine Soon (SES) Telltale Illuminated with Diagnostic Trouble Code (DTC) P0742 Set (Reprogram Transaxle Control Module [TCM]) (05-07-30-006)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM, and TCM) for All Models and All Model Years (05-06-04-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- Crank No Start, Hard Start, Stalling, Or Front Lamps Intermittently Inoperative Setting Any Of The Following Diagnostic Trouble Codes (DTCS) - P0629, B2752, B3722, B3717, B2717, B2600, B2722 (04-06-03-007)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Service Engine Soon (SES) Lamp Illuminated With Diagnostic Trouble Code (DTC) P0496 Set And/Or Hard Start Or Extended Crank After Adding Fuel (Replace EVAP Canister Purge Solenoid Valve) (04-06-04-046)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- SMU - Revised Gm Oil Life System Resetting Procedure (04-00-90-001)
- Entertainment Systems
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Saturn Relay DVD Player/Display (U42/U56) and VUE Rear Seat Display (U32) Ordering Process (05-08-44-015B)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Radio Knobs Available for Service (05-08-44-029A)
- Compact Disc (CD) Player Inoperative - Will Not Load, Will Not Eject or Will Not Play (Remove Both Radio Fuses to Reset Radio) (04-08-44-018)
- XM Radio Labor Operation Codes (03-08-44-001A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- Compact Disc (Cd) Will Not Eject/Load Or Cd Function Inoperative In 6-Disc Cd Mp3 Player/Radio (Reset Cd Player And Complete Questionnaire) (04-08-44-018)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- Popping/Crackling Noise Or Distorted Sound From Speakers At Low Volume When A Compact Disc (Cd) Is Played (Replace RPO U1C Cd Player/Radio With New Design Cd Player/Radio) (04-08-44-016)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Info - Return Form For Compact Discs (CDS) Or Digital Versatile Discs (DVDS) That Are Stuck In Cd Player When Returned As A Core Return (04-08-44-015)
- SMU - Rear Seat Entertainment System (DVD) Diagnostics And Service Procedure (04-08-44-012)
- Theft Deterrent Feature Will Not Set On Cassette Single Cd Player Radio (RPO Up0) (Replace Radio) (04-08-44-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- Service Information Regarding Installation Of A SATURN Radio With Tape Player Into A 2004 Or 2005 Model Year SATURN Vehicle (04-08-44-006)
- Service Information Regarding Radio Upgrade/Downgrade Procedures (04-08-44-003)
- Poor Or Loss Of Fm Radio Reception (Perform Radio Poor Reception Diagnostics And/Or Replace Radio) (03-08-44-021)
- Info - Changes To The U1C Radio On-Board Diagnostic Modes And Cd Load Operation (03-08-44-017)
- Info - Reprogram Radio Using Tech 2 After Radio Replacement (RPOS Us8, Us9, Or UU8) (03-08-44-014)
- Exhaust
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- GM Training - Changes to Saturn Service Training Standards (STS) Requirements for 2009 and 2010 (U.S. Dealers) (09-00-89-021)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Wind Noise at Highway Speeds from Base of Driver Side (Left) A-Pillar Near VIN Plate Area (Seal Area with Seam Sealer) (03-08-58-005B)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Service Manual Update - Addition of Frame Brackets and Serviceable Insulator (Bushing) for L66 Frame (05-08-61-003)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Wind Noise At Highway Speeds From Base Of Driver Side (Left) A-Pillar Near VIN Plate Area (Seal Area With Seam Sealer) (03-08-58-005A)
- Extended Engine Crank Time Before Engine Starts (Replace Primary Fuel Pump) (04-06-04-048)
- Service Engine Soon (SES) Lamp Illuminated With Diagnostic Trouble Code (DTC) P0496 Set And/Or Hard Start Or Extended Crank After Adding Fuel (Replace EVAP Canister Purge Solenoid Valve) (04-06-04-046)
- Service Manual Update - Hood Opening Procedure For Inoperative Hood Latch (04-08-63-003)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Daytime Running Lamps (DRL) May Not Work or DRL Indicator on IP Cluster Flashes and Then Goes Out, DTC B2600 (Inspect DRL Resistor and Replace, If Necessary) (07-08-42-002A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- Crank No Start, Hard Start, Stalling, Or Front Lamps Intermittently Inoperative Setting Any Of The Following Diagnostic Trouble Codes (DTCS) - P0629, B2752, B3722, B3717, B2717, B2600, B2722 (04-06-03-007)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Service Manual Update - Addition of Frame Brackets and Serviceable Insulator (Bushing) for L66 Frame (05-08-61-003)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- Wind Noise At Highway Speeds From Base Of Driver Side (Left) A-Pillar Near VIN Plate Area (Seal Area With Seam Sealer) (03-08-58-005A)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Essential Service Tool Update #2 (U.S. Retailers Only) (06-00-89-021)
- Information on Identifying Proper Design Level and Torque Spec Change for Front Lower Control Arm (05-03-08-011)
- Service Manual Update - Lower Control Arm Ball Stud Nut Torque Specification Changes (05-03-08-003)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Squeak Noise From Front Of Vehicle (Replace Stabilizer Bar End Links) (03-03-08-001A)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Cylinder 1 Miss On Left Turns And Cylinder 4 Miss On Right Turns - Possible Fuel Contamination (PIP3333C)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Service Information Regarding a Pop/Clunk Noise From Rear of Vehicle on Initial Cold Start and/or During Warm-Up Drive Cycle (Inform Customer of Normal EVAP Vent Solenoid Operation) (04-06-05-009C)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Extended Engine Crank Time Before Engine Starts (Replace Primary Fuel Pump) (04-06-04-048)
- Service Engine Soon (SES) Lamp Illuminated With Diagnostic Trouble Code (DTC) P0496 Set And/Or Hard Start Or Extended Crank After Adding Fuel (Replace EVAP Canister Purge Solenoid Valve) (04-06-04-046)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Power Windows and Power Sunroof (if equipped) Inoperative (Install 30A Circuit Breaker) (05-08-64-004)
- Service Manual Update - Wiper/Washer System Schematics (04-08-43-008)
- Gauges & Instrument Panels
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Instrument Panel Cluster (IPC) Lens Cloudy, Scratched, Cracked, or Broken (Replace IPC Lens Only) (06-08-49-002A)
- Squeak or Rattle Noise from Instrument Cluster (Relocate or Install Foam Isolator) (04-08-49-004A)
- SMU - Revised Gm Oil Life System Resetting Procedure (04-00-90-001)
- Speedometer Fluctuation (Replace Input/Output Speed Sensor Assembly) (04-07-30-001)
- Headlights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies (08-08-42-005B)
- Delayed Activation of Automatic Headlamps in Low Ambient Light Conditions (Reprogram Body Control Module [BCM]) (05-08-42-006)
- Heated Glass/Defoggers
- Horns
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- Heater-Ventilation-Air Conditioning (HVAC) Hiss-Type Noise (Replace Low Speed Engine Cooling Fan Resistor) (04-01-37-006)
- Inoperative HVAC Rear Defrost RECIRC, Or Air Condition (Ac) Mode Switches And/Or Reduced Or No Airflow From Vents (Calibrate HVAC Module Controller And/Or Inspect C1 HVAC Controller Connector) (03-01-37-003)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Ignition Lock Cylinder is Hard to Turn or Binds (Clean and Lubricate Ignition Lock Cylinder/Housing) (06-02-35-016C)
- Information on Servicing Vehicles Using New Ignition Start Switch Housing (Ignition Lock Module) Without Steering Column Lock (07-02-35-001)
- Information on Servicing VUE Lock Cylinder Components (05-08-64-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Infotainment
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Interior/Exterior Trim
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Radio Knobs Available for Service (05-08-44-029A)
- Wind Rush or Rustle Noise from Windshield Area at Speeds Above 48-56 km/h (30-35 mph) (Replace Windshield Upper Reveal Molding) (06-08-58-002)
- Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Retailer Installed Accessory (Ria) Luggage Carrier Exhibits A Slow Speed Flutter And/Or High Speed Whistle Noise (Replace Luggage Carrier Slats) (03-08-58-003)
- Squeak Noise From Front Inner Door Armrest/Pull Handle (Replace Front Inner Door Pull Handle PUSHNUTS) (02-08-64-019A)
- Interior/Illumination Lights
- Interior Dome Lamp Will Not Turn Off When Right Front Door Is Closed or Horn Sounds Intermittently in Alarm Mode (Diagnose and Install Foam Support) (05-08-42-002A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- Lubrication System
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SMU - Revised Gm Oil Life System Resetting Procedure (04-00-90-001)
- Info - Oil Filter Cap Assembly And Oil Filter Element Design Change (03-00-90-003)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Information On Serpentine Belt Wear (04-06-01-013)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Mechanical
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Whine Noise From Timing Chain Area (PIP3535D)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Oil Leak from Engine Front Cover Crankshaft Oil Seal During Extremely Cold Weather (Replace Crankshaft Front Oil Seal) (04-06-01-009A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- Slight Loss Of Coolant Or Low Coolant Light Coming On With No Signs Of External Leaks (Perform Service Procedure In This Bulletin) (03-06-123-001)
- Mechanical - Hydraulic
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Disc Brake Warranty Service and Procedures - Lateral Runout (LRO), Rotor Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Corrosion, Squeak, Grind, Groan (05-05-22-002E)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Rattle Noise from Front of Vehicle at Slow Speeds on Rough Surfaces When Brake Pedal Is Not Applied (Install New Caliper Pin Bushing) (05-05-23-005A)
- Rattle Noise from Front of Vehicle at Slow Speeds on Rough Surfaces When Brake Pedal Is Not Applied (Install New Caliper Pin Bushing) (05-05-23-005)
- Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
- Mirrors
- Paint & Coatings
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Warranty Information-Fascia Refinish Labor Operations (10-08-62-003)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004A)
- Info - Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004)
- Parking Brake System
- Passive Restraints
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Essential Service Tool Update #2 (U.S. Retailers Only) (06-00-89-021)
- VUE Rear Suspension Torque Specifications (05-03-09-005)
- Service Manual Update - Lower Control Arm Ball Stud Nut Torque Specification Changes (05-03-08-003)
- Restraints Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006D)
- Seat Cushion Cover Loose (Secure J-Strip to Seat Frame With Hog Rings) (06-08-50-005D)
- Squeak/Itch Noise from Front Seat(s) Upon Turning or Lateral Movement (Install Squeak Reduction Tape to Front Seat Hook) (02-T-21)
- Front Seat Armrest Angled Down When Seat Is In Upright Position (Determine Armrest Angle) (04-08-50-004)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Intermittent No Crank, No Start (03-06-03-006A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- Steering Column
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Information on Servicing Vehicles Using New Ignition Start Switch Housing (Ignition Lock Module) Without Steering Column Lock (07-02-35-001)
- Scraping Noise from Upper Steering Column Behind Steering Wheel (Reposition Inflatable Restraint Steering Wheel Module Wires) (04-09-41-005A)
- Rattle Noise From Steering Column (Replace Steering Column) (04-02-35-006)
- Steering Control Systems
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Sunroof Frame Tox Rivet Rattle (Install Flocking Tape) (09-08-67-001)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Power Windows and Power Sunroof (if equipped) Inoperative (Install 30A Circuit Breaker) (05-08-64-004)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Suspension Control Systems
- System
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Cruise Control Inoperative and/or Service Vehicle Soon (SVS) "Wrench" Telltale Illuminated with Diagnostic Trouble Code (DTC) P0571 Stored in Powertrain Control Module (PCM) (Reprogram PCM) (04-08-68-004B)
- Service Engine Soon (SES) Telltale Illuminated with Diagnostic Trouble Code (DTC) P0742 Set (Reprogram Transaxle Control Module [TCM]) (05-07-30-006)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM, and TCM) for All Models and All Model Years (05-06-04-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Extended Engine Crank Time Before Engine Starts (Replace Primary Fuel Pump) (04-06-04-048)
- Service Engine Soon (SES) Lamp Illuminated With Diagnostic Trouble Code (DTC) P0496 Set And/Or Hard Start Or Extended Crank After Adding Fuel (Replace EVAP Canister Purge Solenoid Valve) (04-06-04-046)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SMU - Revised Gm Oil Life System Resetting Procedure (04-00-90-001)
- Towing
- Towing Systems
- Transfer Case
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Limited Service Repair Program for All-Wheel Drive (AWD) Transfer Case Assembly (RPO MJ8) (03-07-30-039B)
- Moan/Grown Noise/Vibration From Rear Of Vehicle When Turning At Low Speeds (Replace Rear Drive Module Differential Clutch Drum) (03-04-20-003B)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- Service Manual Update For RTV Sealant Usage On The Rear Drive Module (04-04-20-002)
- Transmission Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- M16, M75 VT25E (VTi) Transaxle - Information on Damage to Input Hub Seal and/or Variable Drive Pulley Follower After Case Cover Replacement, DTCs P0741, P0742, P1882 (07-07-30-016)
- Service Engine Soon (SES) Telltale Illuminated with Diagnostic Trouble Code (DTC) P0742 Set (Reprogram Transaxle Control Module [TCM]) (05-07-30-006)
- Intermittent Hesitation During Vehicle Launch (Replace Transaxle Input/Output Sensors or Transaxle Case Cover Assembly, If Necessary) (05-07-30-003)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- Low Speed Grind Noise And/Or Hesitation While Driving (Install New Transmission Control Module (TCM) Calibration And Add New Transmission Fluid And Additive) (03-07-30-051A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- No Wheel Movement In Snow Or Slippery Surfaces (Reprogram TCM) (04-07-30-007)
- Speedometer Fluctuation (Replace Input/Output Speed Sensor Assembly) (04-07-30-001)
- Service Information Regarding Transaxle Poor Performance After Case Cover Replacement, DTC P1882 Set (03-07-30-048)
- Warning Systems
- Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Rear Toe Cam Adjustment Nut For Service Applications (PIT3117J)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- Info - New Measuring Wheel Alignment Procedure For Labor Operation Numbers E2020 And E2000 (04-03-07-003)
- Wheels & Tire System
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Revised Wheel Nut Torque Specification (05-03-10-014)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- GM New Vehicle Tire Warranty Program (U.S. Only) (05-03-10-009)
- Quick Tips for Warranty Administration (05-00-89-007)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Wind Rush or Rustle Noise from Windshield Area at Speeds Above 48-56 km/h (30-35 mph) (Replace Windshield Upper Reveal Molding) (06-08-58-002)
- Power Windows and Power Sunroof (if equipped) Inoperative (Install 30A Circuit Breaker) (05-08-64-004)
- Aftermarket Window Tinting Scratched Or Torn (Replace Side Door Inner Sealing Strips) (03-08-64-030)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Prior To Any Circuit Testing (PIP5094A)
- Service Manual Update - Wiper/Washer System Schematics (04-08-43-008)
- Crank No Start, Hard Start, Stalling, Or Front Lamps Intermittently Inoperative Setting Any Of The Following Diagnostic Trouble Codes (DTCS) - P0629, B2752, B3722, B3717, B2717, B2600, B2722 (04-06-03-007)