Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
- Smart Key Battery Diagnostics (T-SB-0122-08 REV1)
- Remote Engine Starter (Res) Cold Temperature Operation Diagnostic Tips (T-SB-0100-09 (REV 1))
- Vehicle Start After Battery Depletion (EL017-06)
- Smart Key System Check (PD017-05 REV.)
- Failure To Initialize Can Interface Module (SS001-05)
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- Seat Cover Replacement For Side Airbag Equipped Vehicles (T-SB-0122-11 REV1)
- SRS Component Disposal As Hazardous Material Treatment (T-SB-0218-17 REV1)
- SRS Precautions - Crib # 160 (T-CRIB-160)
- Repair Manual Supplement: Supplemental Restraint (EL003-07)
- Seat Cover Replacement For Side Airbag Equipped Vehicles (BO025-97)
- Anti-Lock Brakes
- Anti-Theft Systems
- Immobilizer And Smart Key Reset (T-SB-0057-18 REV2)
- Smart Key Battery Diagnostics (T-SB-0122-08 REV1)
- Smart Key Intermittent No Crank/No Start (T-SB-0003-09-REV1)
- Remote Engine Starter (Res) Cold Temperature Operation Diagnostic Tips (T-SB-0100-09 (REV 1))
- Smart Key Specifications (EL015-06)
- Programming OEM Wireless Door Lock Remote Transmitters (EL009-07)
- Wireless Transmitter & Programming Guide (EL010-07)
- Repair Manual Supplement Smart Key (EL001-06)
- Vehicle Start After Battery Depletion (EL017-06)
- Diagnostic Tester Immobilizer Functions (SS003-02)
- Smart Key System Check (PD017-05 REV.)
- 2005 My AVALON Pre-Delivery Service (PDS) (PD006-05 REV.)
- Automatic Door Lock/Unlock Functions (PG005-05)
- Automatic Trans
- Automatic/Continuously Variable Transmission Replacement Precautions (T-SB-0024-18)
- World Standard Automatic Transmission Fluid (TC010-07)
- Alignment Pin Installation During Transmission/Transaxle Assembly Installation (T-SB-0053-08)
- Automatic Transmission Shipping Bag For Warranty Recovery (TC012-07)
- Automatic Door Lock/Unlock Functions (PG005-05)
- Auxiliary Emission Control Systems
- Battery Management Systems
- Body Electrical
- Body Interior
- Brakes Control Systems
- Charging Systems
- Communication Devices
- Cooling System (Mechanical)
- Cruise Control Systems
- Driveshaft & Universal Joints
- Engine Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
- Mil "On" DTC P0138, P0158 And/Or P0606 Diagnostic Tips (T-SB-0001-10 REV1)
- Mil "On" DTC P0456 (T-SB-0042-12)
- Mil "On" DTC P0500 (T-SB-0341-09 REV1)
- 2GR-FE Engine Ticking Noise And/Or Mil "On" P0014, P0015, P0024, P0025, P0017, Or P0018 (T-SB-0094-09-REV1)
- Engine Bank 1 And Bank 2 A/F And O2 Identification (T-SB-0398-09)
- 2GR-FE Mil "On" DTC P0505 (T-SB-0184-09)
- IG1 Relay Freezing (T-SB-0167-09)
- ECM Calibration: Enhancement To Shifting Performance & Smoothness (EG033-07)
- Entering VIN During ECM (Pcm) Replacement And/Or DTC P0630 (EG045-04 REV.)
- ECM Reset Memory Function (TC002-03)
- Entertainment Systems
- Exterior Body Panels
- PAINTLESS Dent Repair - Crib # 146 (T-CRIB-146)
- Sealing Hem-Flanges & Body Seams - Crib # 163 (T-CRIB-163)
- Water Leak At Front Floor (T-SB-0339-10)
- Plastic Bumper Refinishing - Crib # 170 (L-CRIB-170)
- Front Fender Liner Pin Hold Clip Removal/Installation Procedures (T-SB-0073-08)
- Corrosion Prevention & Sound Absorbing Measures - Crib # 159 (L-CRIB-159)
- Creaking Or Ticking Noise From Base Of Rear Window (NV014-06)
- Rear Spoiler Isolator Gasket (AX005-05)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Mil "On" DTC P0138, P0158 And/Or P0606 Diagnostic Tips (T-SB-0001-10 REV1)
- Accelerator Pedal Sensor Assembly Service Precaution (T-SB-0087-12)
- Mil "On" DTC P0456 (T-SB-0042-12)
- Accelerator Pedal Bracket Damaged (T-SB-0335-10)
- Fuel Injector Cleaning (PG011-05)
- M.I.L. "On" DTC P0171, P0174, P2195, Or P2197 (EG050-05)
- M.I.L. "On" DTC P043E, P043F, P2401, P2402, & P2419 (EG019-06)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Hazardous Waste Material
- HVAC Control Systems
- Identification
- Replacement Certification Labels And VIN Plates (T-SB-0032-20 REV2)
- Replacement VIN Plates (PG009-02)
- Replacement VIN Plates (PG005-97)
- Ca/Fed/50 State Certified Emission Control UNDERHOOD Labels (T-SB-0054-13)
- Engine Serial Number Location (T-SB-0301-08 REV1)
- Replacement Certification Labels And VIN Plates - Crib # 164 (S-CRIB-164)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Prevention And Repair Of Acid Rain Damage (T-SB-091-020)
- Odor Remediation Process (Dealer Performed) (T-SB-0055-24 REV1)
- Carpet Floor Retainer Serviceability (T-SB-0014-22)
- Carpet Grommet Serviceability (T-SB-0397-09 REV2)
- Instrument Panel (Dashboard) Cracked And/Or Sticky (T-SB-0039-15 REV1)
- Water Leak At Headliner (T-SB-0037-11)
- Floor Carpet Service Part Installation (T-SB-0266-10)
- LH Or RH A-Pillar Garnish Loose Or Dropping Down (T-SB-0178-09)
- Cup Holder Replacement (T-SB-0150-08)
- Trim Removal & Installation - Crib # 167 (L-CRIB-167)
- Front Fender Liner Pin Hold Clip Removal/Installation Procedures (T-SB-0073-08)
- Cassette Door Replacement (BO005-06)
- Tray Box Replacement (BO006-06)
- Trim Garnish Loose (BO017-03)
- Front License Plate Mounting Bracket & License Plate Installation (PD005-05 REV.)
- Refinishing Replacement Bumper Covers (PA003-02 REV.)
- Lubrication System
- Manual Steering
- Mechanical
- Oil Leak Diagnosis And Repair (T-SB-0008-20)
- Torque Converter Bolt Installation (T-SB-0014-11 REV1)
- Rear Cam Alignment (PA008-11)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Mil "On" VVT-I DTCS - Oil Control Valve (OCV) (T-SB-0105-11)
- 2GR-FE Engine Ticking Noise And/Or Mil "On" P0014, P0015, P0024, P0025, P0017, Or P0018 (T-SB-0094-09-REV1)
- 2GR-FE No. 2 Idler Pulley Noise (T-SB-0056-09)
- Engine Serial Number Location (T-SB-0301-08 REV1)
- 2GR-FE Valve Timing Procedure (T-SB-0291-08)
- Cylinder Head Cover Baffle Precautions (T-SB-0038-08)
- 2GR-FE Engine Oil Leak From Front Timing Cover (EG019-07)
- 2GR-FE (V6) Engine Oil Leak (EG038-06)
- Main Bearing Journal Diameter Stamping Location Revision (EG044-04)
- Mechanical - Hydraulic
- Mirrors
- Paint & Coatings
- New Vehicle Washing Schedule For Paint Protection (T-SB-0039-24 REV2)
- Prevention And Repair Of Acid Rain Damage (T-SB-091-020)
- RAPGARD Protective Film Removal (T-SB-0061-23 REV2)
- Iron Particle Rust Contamination Repair (TS-PA005-04)
- PAINTLESS Dent Repair - Crib # 146 (T-CRIB-146)
- Water Leak At Front Floor (T-SB-0339-10)
- Long Term Vehicle Storage Guidelines (T-SB-0079-09 REV1)
- Plastic Bumper Refinishing - Crib # 170 (L-CRIB-170)
- Permanent-Type Protective Wax Coatings (T-SB-0138-08)
- Acid Rain Paint Finish Damage - Prevention & Repair - Crib # 165 (S-CRIB-165)
- Paint Stains Under RAPGARD™ (PA002-02)
- Protective Film Removal - Outside Door Handle Area (PD042-04 REV.)
- Iron Particle Rust Contamination Repair (PA005-04)
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Seats
- Seat Cover Replacement For Side Airbag Equipped Vehicles (T-SB-0122-11 REV1)
- Limited Driver's Seat Cushion Cover Side Vinyl Cracking (T-SB-0188-09)
- Front Seat Squeak Noise (T-SB-0288-08 REV1)
- Front Power Seat Grinding/Groaning Noise (T-SB-0253-08)
- Seat Cover Replacement For Side Airbag Equipped Vehicles (BO025-97)
- Starter
- Steering Column
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Mil "On" DTC P0138, P0158 And/Or P0606 Diagnostic Tips (T-SB-0001-10 REV1)
- Mil "On" DTC P0456 (T-SB-0042-12)
- Accelerator Pedal Bracket Damaged (T-SB-0335-10)
- Mil "On" DTC P0500 (T-SB-0341-09 REV1)
- 2GR-FE Engine Ticking Noise And/Or Mil "On" P0014, P0015, P0024, P0025, P0017, Or P0018 (T-SB-0094-09-REV1)
- 2GR-FE Mil "On" DTC P0505 (T-SB-0184-09)
- M.I.L "On" DTC P2195, P2197, P0138, P0158, P0171, P0174, P0031, Or P0051 (T-SB-0114-08)
- M.I.L. "On" DTC P0171, P0174, P2195, Or P2197 (EG050-05)
- M.I.L. "On" DTC P043E, P043F, P2401, P2402, & P2419 (EG019-06)
- Entering VIN During ECM (Pcm) Replacement And/Or DTC P0630 (EG045-04 REV.)
- Failure To Initialize Can Interface Module (SS001-05)
- ECM Reset Memory Function (TC002-03)
- Transmission Control Systems
- Warning Systems
- Wheel Alignment
- Wheels & Tire System
- Window Motors & Regulators
- Upper/Lower Windshield/Rear Glass Tick Noise (T-SB-0141-10)
- Front Door Glass Operation Improvement (BO013-07)
- Creaking Or Ticking Noise From Base Of Rear Window (NV014-06)
- Upper/Lower Windshield Tick Noise (TSB2646)
- Power System Initialization During PDS (PD008-05)
- Initialization Of Power Window (PD002-05)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)