Technical Service Bulletins: Other Variant
WARNING: This page is about the Highlander Hybrid, which is a different variant/trim than selected.
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
- Smart Key Specifications (T-SB-0033-13)
- Smart Key Battery Diagnostics (T-SB-0122-08 REV1)
- IG1 Relay Freezing (T-SB-0047-09 REV2)
- Remote Engine Starter (Res) Cold Temperature Operation Diagnostic Tips (T-SB-0100-09 (REV 1))
- Audio BLUETOOTH System Outgoing Call Volume Adjustment (T-SB-0097-09)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Immobilizer And Smart Key Reset (T-SB-0057-18 REV2)
- Smart Key Specifications (T-SB-0033-13)
- Rust Stain Below Outside Door Handle (T-SB-0159-11 REV2)
- False Security Alarm Operation (T-SB-0200-10 REV1)
- Smart Key Battery Diagnostics (T-SB-0122-08 REV1)
- Smart Key Intermittent No Crank/No Start (T-SB-0003-09-REV1)
- Remote Engine Starter (Res) Cold Temperature Operation Diagnostic Tips (T-SB-0100-09 (REV 1))
- Smart Key Specifications (EL015-06)
- Wireless Transmitter & Programming Guide (EL010-07)
- Automatic Trans
- Automatic/Continuously Variable Transmission Replacement Precautions (T-SB-0024-18)
- HV Transaxle Repair Components Available (T-SB-0150-14)
- Remanufactured Automatic Transmission Serial Number Location (TC013-06)
- World Standard Automatic Transmission Fluid (TC010-07)
- Automatic Transmission Serial Number Location (TC012-06)
- Gates G-Force CVT Belt Installation (TT004-13)
- Special Service Tools (T-SB-0302-08)
- Auxiliary Emission Control Systems
- Axle Shafts
- Battery Management Systems
- Body Electrical
- Brakes Control Systems
- Charging Systems
- Communication Devices
- Cooling System (Mechanical)
- Differentials & Drive Axles
- Engine Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
- Mil On With DTC P0A80/P1AC0-00 And/Or P0A7F/P1A80-00 Due To Dust Or Debris In The HV Battery Cooling Fan/Filter (T-SB-0074-20)
- Mil "On" DTC P0138, P0158 And/Or P0606 Diagnostic Tips (T-SB-0001-10 REV1)
- Mil "On" DTC P030# At Cold Startup (T-SB-0210-11)
- Mil "On" DTC P1423 Or Fuel Cap Binding (T-SB-0027-11)
- 2GR-FE Engine Ticking Noise And/Or Mil "On" P0014, P0015, P0024, P0025, P0017, Or P0018 (T-SB-0094-09-REV1)
- Mil "On" DTC P0351, P0352, P0353, P0354, P0355, P0356 (T-SB-0047-10)
- Engine Bank 1 And Bank 2 A/F And O2 Identification (T-SB-0398-09)
- IG1 Relay Freezing (T-SB-0047-09 REV2)
- 2GR-FE Mil "On" DTC P0505 (T-SB-0184-09)
- M.I.L. "On" DTC P0A78 With Information Codes 286, 287 (T-SB-0386-08)
- ISC Learning Procedure (EG037-07)
- Entertainment Systems
- Exterior Body Panels
- Power Back Door System Has Abnormal Closing Operation (T-SB-0191-17 REV1)
- PAINTLESS Dent Repair - Crib # 146 (T-CRIB-146)
- Sealing Hem-Flanges & Body Seams - Crib # 163 (T-CRIB-163)
- Rust Stain Below Outside Door Handle (T-SB-0159-11 REV2)
- Mil "On" DTC P1423 Or Fuel Cap Binding (T-SB-0027-11)
- Noise From Front Window/Door Check (T-SB-0027-10 REV2)
- Plastic Bumper Refinishing - Crib # 170 (L-CRIB-170)
- Corrosion Prevention & Sound Absorbing Measures - Crib # 159 (L-CRIB-159)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Hazardous Waste Material
- HVAC Control Systems
- Identification
- Replacement Certification Labels And VIN Plates (T-SB-0032-20 REV2)
- Replacement VIN Plates (PG009-02)
- Replacement VIN Plates (PG005-97)
- Remanufactured Automatic Transmission Serial Number Location (TC013-06)
- Automatic Transmission Serial Number Location (TC012-06)
- Ca/Fed/50 State Certified Emission Control UNDERHOOD Labels (T-SB-0054-13)
- Engine Serial Number Location (T-SB-0301-08 REV1)
- Replacement Certification Labels And VIN Plates - Crib # 164 (S-CRIB-164)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Prevention And Repair Of Acid Rain Damage (T-SB-091-020)
- Odor Remediation Process (Dealer Performed) (T-SB-0055-24 REV1)
- Carpet Floor Retainer Serviceability (T-SB-0014-22)
- Door Armrest Cracking Or Separating (T-SB-0030-11)
- Rear Ac Vents Loose (T-SB-0253-10 REV1)
- Trim Removal & Installation - Crib # 167 (L-CRIB-167)
- Overhead Console Stuck Open (T-SB-0083-08)
- Floor Mat Installation During PDS (PD137-07)
- Roof Rack Leg Cover Installation During PDS (PD035-07)
- Lubrication System
- Manual Steering
- Mechanical
- Oil Leak Diagnosis And Repair (T-SB-0008-20)
- Torque Converter Bolt Installation (T-SB-0014-11 REV1)
- Rear Cam Alignment (PA008-11)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Oil Cooler Pipe Leak/Seep (T-SB-0201-11)
- Mil "On" VVT-I DTCS - Oil Control Valve (OCV) (T-SB-0105-11)
- 2GR-FE Engine Ticking Noise And/Or Mil "On" P0014, P0015, P0024, P0025, P0017, Or P0018 (T-SB-0094-09-REV1)
- Oil Leak From Engine Bell Housing - Oil Galley Plug (T-SB-0062-09)
- 2GR-FE No. 2 Idler Pulley Noise (T-SB-0056-09)
- Oil Leak From Camshaft Housing (T-SB-0321-08)
- Special Service Tools (T-SB-0302-08)
- Engine Serial Number Location (T-SB-0301-08 REV1)
- 2GR-FE Valve Timing Procedure (T-SB-0291-08)
- Cylinder Head Cover Baffle Precautions (T-SB-0038-08)
- Short Pin & Engine Compartment Side Cover Installation During PDS (PD124-07)
- Mechanical - Hydraulic
- Wheel Film For Brake Rotor Rust Prevention (T-SB-0038-24 REV2)
- Customer Support Program ZKC - Certain 2008-2010 Model Year Highlander Hybrid Vehicles - Coverage For Brake Actuator Assembly And Brake Booster Pump Assembly (T-CP-ZKC-A110-D)
- Abs Brake Warning Light On (T-SB-0064-19)
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- Brake Pedal Force Gauge SST For Parking Brake (T-SB-0141-13)
- Brake Booster Rattle/Buzz Noise (T-SB-0229-09)
- Special Service Tools (T-SB-0302-08)
- Paint & Coatings
- New Vehicle Washing Schedule For Paint Protection (T-SB-0039-24 REV2)
- Prevention And Repair Of Acid Rain Damage (T-SB-091-020)
- RAPGARD Protective Film Removal (T-SB-0061-23 REV2)
- Iron Particle Rust Contamination Repair (TS-PA005-04)
- PAINTLESS Dent Repair - Crib # 146 (T-CRIB-146)
- Chip Resistant Coatings - Crib # 141 (L-CRIB-141)
- Long Term Vehicle Storage Guidelines (T-SB-0079-09 REV1)
- Plastic Bumper Refinishing - Crib # 170 (L-CRIB-170)
- Permanent-Type Protective Wax Coatings (T-SB-0138-08)
- Acid Rain Paint Finish Damage - Prevention & Repair - Crib # 165 (S-CRIB-165)
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Starter
- High Voltage (HV) Battery Rescue Charge (HEV Workstation/GRX-5100) (T-SB-0119-15 REV2)
- HV Battery Cooling Fan Maintenance For Severe Usage Vehicles (T-SB-0198-11 REV1)
- Mil On With DTC P0A80/P1AC0-00 And/Or P0A7F/P1A80-00 Due To Dust Or Debris In The HV Battery Cooling Fan/Filter (T-SB-0074-20)
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- Smart Key Battery Diagnostics (T-SB-0122-08 REV1)
- Long Term Vehicle Storage Guidelines (T-SB-0079-09 REV1)
- HV Battery Cover Service (T-SB-0037-08)
- Maintenance For HV & Auxiliary Batteries (PD125-07)
- Absorbed Glass Mat (AGM) Battery Information (SS006-07)
- Steering Column
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Mil "On" DTC P0138, P0158 And/Or P0606 Diagnostic Tips (T-SB-0001-10 REV1)
- Mil "On" DTC P030# At Cold Startup (T-SB-0210-11)
- Mil "On" DTC P1423 Or Fuel Cap Binding (T-SB-0027-11)
- 2GR-FE Engine Ticking Noise And/Or Mil "On" P0014, P0015, P0024, P0025, P0017, Or P0018 (T-SB-0094-09-REV1)
- Mil "On" DTC P0351, P0352, P0353, P0354, P0355, P0356 (T-SB-0047-10)
- 2GR-FE Mil "On" DTC P0505 (T-SB-0184-09)
- M.I.L. "On" DTC P0A78 With Information Codes 286, 287 (T-SB-0386-08)
- Transfer Case
- Transmission Control Systems
- Wheel Alignment
- Wheels & Tire System
- Tire Repair Resources (T-SB-0187-12 REV2)
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- Tire Positioning Before New Vehicle Delivery (T-SB-0204-10)
- Long Term Vehicle Storage Guidelines (T-SB-0079-09 REV1)
- Tire Inflation Pressure Compensation And Adjustment (T-SB-0345-08 REV2)
- Tire Pressure Monitoring System (TPMS) Tire Registration "Lost Communication With Ecu" (T-SB-0084-09)
- Tire Pressure Warning Valve/Sensor Activation (PD133-07)
- Tire Pressure Warning Valve/Sensor Activation (PD022-07)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)