Technical Service Bulletins: Other Variant
WARNING: This page is about the 244 Base, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Replacing Pulley & Magnetic Clutch On A/C Compressor (GROUP 87, NO. 214)
- New A/C Compressor Tools Descriptions (GROUP 00, NO. 103)
- Conversion Of A/C System From R12 To R134A Retrofit (GROUP 87, NO. 217)
- New A/C Hose O-Rings (GROUP 87, NO. 119)
- FREON Loss - New Filler Valve (GROUP 87, NO. 202)
- A/C Leak At Metal Elbow - Remove Clamp (GROUP 87, NO. 116)
- Accessories & Equipment
- Accessories Control Systems
- Anti-Theft Systems
- Automatic Trans
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Automatic Transmission Cooler/Lines Flushing (43-56)
- Automatic Transmission Diagnostic Sheet (43-08)
- Transmission And AWD Lubricants (40-04)
- Installation Of Pinion Seal (GROUP 46, NO. 204)
- ATF Filter Cleaning/Insp Deleted At Service Interval (GROUP 17, NO. 106)
- Automatic Transmission Fluid Application (GROUP 43, NO. 112)
- Reseal Speedo Cable After Every Repair (GROUP 38, NO. 702)
- Fuel Injector Maintenance Cleaning (GROUP 23, NO. 129)
- Exchange Automatic Trans Installation Steps (GROUP 43, NO. 110)
- Microprocessor Assisted Shift Indicator DIAGNOSIIC (GROUP 36, NO. 105)
- Auxiliary Emission Control Systems
- Oxygen Sensor Thread Repair Method (TJ 35818.1.1)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- Engine Management Systems And Control Modules (GROUP 28, NO. 206)
- New EPROM Kit - Service Manual Revision (GROUP 28, NO. 920)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- New EZ-116K Impulse Sender/Specification (GROUP 28, NO. 104)
- 2.3L Eng Exchange Fuel Injection Control Unit (GROUP 23, NO. 138)
- 2.1/2.3/2.7/2.8 L Eng Revised Carbon Filter (GROUP 23, NO. 207)
- 2.3L Eng Cold Start Stall Under Load - New Ecu (GROUP 23, NO. 204)
- Rough/Unstable Idle - New Crankcase Ventilation Hose (GROUP 25, NO. 112)
- 2.3L Eng Unstable Idle - Cis Air Valve/Idle Adj. (GROUP 23, NO. 131)
- B23F/B230F Eng Air Hose Leak - Clamp Cable Harness (GROUP 37, NO. 23)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Installation Of Cooling Thermostat - Procedure (GROUP 26, NO. 204/910)
- Water Pump Inspection (GROUP 26, NO. 31)
- Asbestos-Free Valve Cover Gasket Replacement (GROUP 21, NO. 13+70)
- D24/D24T Injection Pump Shaft Seal R & R (GROUP 23, NO. 30)
- D24 Engine Head Gasket Revised (GROUP 21, NO. 68)
- D24/D24T Engine P20 - Acceleration Test (GROUP 23, NO. 128)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Control Module Swapping (TJ 31946.1.2)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- Engine Management Systems And Control Modules (GROUP 28, NO. 206)
- New EPROM Kit - Service Manual Revision (GROUP 28, NO. 920)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- New EZ-116K Impulse Sender/Specification (GROUP 28, NO. 104)
- 2.3L Eng Exchange Fuel Injection Control Unit (GROUP 23, NO. 138)
- 2.3L Eng Cold Start Stall Under Load - New Ecu (GROUP 23, NO. 204)
- 2.3L Eng Unstable Idle - Cis Air Valve/Idle Adj. (GROUP 23, NO. 131)
- B23F/B230F Eng Air Hose Leak - Clamp Cable Harness (GROUP 37, NO. 23)
- Entertainment Systems
- Control Module Swapping (TJ 31946.1.2)
- Stuck CDS In Audio Units (All Models) (TNN 39-51)
- Power Antenna Modification (GROUP 39, NO. 114)
- Radio Fault Tracing P20 & P70 (GROUP 39, NO. 03)
- Power Mirror Adjustment: Popping Noise In Audio SYS. (GROUP 39, NO. 108)
- Power Antenna - Fault Tracing (GROUP 39, NO. 105)
- Radio With Microprocessor - Disconnect Caution (GROUP 39, NO. 103)
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- New Bushing Press Tools/Supplier Information (GROUP 00, NO. 96)
- Replacing Trailing Arm Bushing (GROUP 65, NO. 203)
- Rear SUSP Spring Noise - Remove Excess Undercoating (GROUP 77, NO. 103)
- Steering Wheel Vibration - Control Arm Rear Bushing (GROUP 77, NO. 102)
- Fuel System
- Fuses & Circuit Breakers
- New Cable Terminal As A Replacement Part (GROUP 37, NO. 207)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- Measurement Of Voltage Drop Across Ground Connection (GROUP 37, NO. 204)
- New Sealed Crimping Sleeve For Wiring Connections (GROUP 37, NO. 701)
- Sealing Of Wire Splices With Shrink Sleeve (GROUP 37, NO. 201)
- No 11 (16 Amp) Fuse Overload Repair (GROUP 37, NO. 102)
- Gauges & Instrument Panels
- Coolant Temperature Gauge - False Reading (GROUP 38, NO. 203)
- Odometer Replacement - Information Sticker (GROUP 38, NO. 114)
- Fuel Level Reads Low - Potentiometer Modification (GROUP 38, NO. 201)
- Speedo Needle Vibrates - Transmitter And/Or Cable (GROUP 38, NO. 2)
- Erratic/High Temperature Gauge - Clean Contacts (GROUP 38, NO. 108)
- Erratic VDO Speedometer - Replace Circuit Board Clip (GROUP 38, NO. 106)
- New Fuel Gauge Sender Installation (GROUP 38, NO. 104)
- Headlights
- HVAC Control Systems
- Retailer Technical Journal 19292 Climate Control System, Cleaning (TJ 19292)
- Replacing Pulley & Magnetic Clutch On A/C Compressor (GROUP 87, NO. 214)
- New A/C Compressor Tools Descriptions (GROUP 00, NO. 103)
- Conversion Of A/C System From R12 To R134A Retrofit (GROUP 87, NO. 217)
- Cleaning The Heater Unit Drainage Hose (GROUP 87, NO. 219)
- New Heater Control Valve For Climate Control System (GROUP 87, NO. 211)
- Improved A/C Performance - Install Fan (GROUP 87, NO. 123)
- A/C System Drainage (GROUP 87, NO. 212)
- New A/C Hose O-Rings (GROUP 87, NO. 119)
- FREON Loss - New Filler Valve (GROUP 87, NO. 202)
- Leakage At A/C Compressor Filler Valve - New Valve (GROUP 87, NO. 701)
- Poor Defrost - Modify Rear Side Air Vents (GROUP 87, NO. 2)
- A/C Filler Valve Caution - New Valve (GROUP 87, NO. 117)
- A/C Leak At Metal Elbow - Remove Clamp (GROUP 87, NO. 116)
- Identification
- Ignition System
- Ignition System Replacement (GROUP 37, NO. 11)
- New EZ-116K Impulse Sender/Specification (GROUP 28, NO. 104)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- 2.3/2.8L Eng Checking Constant Idle Stabilizer Valve (GROUP 23, NO. 710)
- Poor DRIVEABILITY - Intake Valve Carbon Buildup (GROUP 00, NO. 101)
- D24/D24T Injection Pump Shaft Seal R & R (GROUP 23, NO. 30)
- D24 Engine - Cold Start Device/Idle Speed Adjustment (GROUP 23, NO. 2)
- D24/D24T Engine P20 - Acceleration Test (GROUP 23, NO. 128)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- 2.3L Eng Noise/Lack Of Power - Revised Fuel Pump (GROUP 23, NO. 132)
- EZ117/118K Ignition Diagnosis (GROUP 34, NO. 4)
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Oil Consumption Test (TJ 35526.1.6)
- Expendable Items Parts List (SMB00-108D)
- Engine Oil Consumption Test FAQ (SMB22-006)
- Recommended Engine Oils (GROUP 22, NO. 3)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Identification Of Abnormal Oil Consumption (GROUP 22, NO. 107)
- Oil Viscosity - When Enough Is Enough (GROUP 17, NO. 4)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- Fuel Injector Maintenance Cleaning (GROUP 23, NO. 129)
- Asbestos-Free Valve Cover Gasket Replacement (GROUP 21, NO. 13+70)
- D24/D24T Injection Pump Shaft Seal R & R (GROUP 23, NO. 30)
- D24 Engine Head Gasket Revised (GROUP 21, NO. 68)
- D24/D24T Engine P20 - Acceleration Test (GROUP 23, NO. 128)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- Manual Steering
- Manual Trans
- Transmission And AWD Lubricants (40-04)
- Installation Of Pinion Seal (GROUP 46, NO. 204)
- Improved Reverse Shift Quality Modifications (GROUP 43, NO. 116)
- Manual Trans. Rebuilding Quality - Longer Dog-Keys (GROUP 43, NO. 115)
- Manual Trans. - New Driven Plates & Release Bearing (GROUP 41, NO. 105)
- M46/M47II Trans New First Gear & Bearing (GROUP 43, NO. 113)
- Automatic Transmission Fluid Application (GROUP 43, NO. 112)
- Reseal Speedo Cable After Every Repair (GROUP 38, NO. 702)
- M46 Trans Broken/Loose MAINSHAFT CIRCLIPS - Rev Clip (GROUP 43, NO. 93)
- M4 Gearbox Oil Capacity Increased (GROUP 43, NO. 97)
- Mechanical
- VOLVO Engine Oil Consumption (SMB22-007)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Replacement Of Press Bolts On TWC Converter - Info (GROUP 25, NO. 207/912)
- Identification Of Abnormal Oil Consumption (GROUP 22, NO. 107)
- Piston Clearance In Used Engines - Inspection/Specs. (GROUP 21, NO. 209/718)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- 2.3/2.8L Eng Checking Constant Idle Stabilizer Valve (GROUP 23, NO. 710)
- Poor DRIVEABILITY - Intake Valve Carbon Buildup (GROUP 00, NO. 101)
- Valve Cover Oil Seepage - Check Valve Cover Nuts (GROUP 17, NO. 104)
- 2.0/2.3L Eng Crank Rumble Noise - New Main Bearing (GROUP 21, NO. 74)
- Valve Guide Press-In (GROUP 21, NO. 71)
- Asbestos-Free Valve Cover Gasket Replacement (GROUP 21, NO. 13+70)
- D24/D24T Injection Pump Shaft Seal R & R (GROUP 23, NO. 30)
- D24 Engine - Cold Start Device/Idle Speed Adjustment (GROUP 23, NO. 2)
- D24 Engine Head Gasket Revised (GROUP 21, NO. 68)
- D24/D24T Engine P20 - Acceleration Test (GROUP 23, NO. 128)
- Fuel Pump Noise - Pressure Damper (GROUP 23, NO. 130)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- 2.3L Eng Noise/Lack Of Power - Revised Fuel Pump (GROUP 23, NO. 132)
- 4-Cylinder Engine Compression Test (GROUP 21, NO. 117)
- B21FT Eng Turbocharger Replacement (GROUP 25, NO. 107)
- Mechanical - Hydraulic
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- New Body Repair Equipment And Chemicals-Information (GROUP 80, NO. 205)
- Water Sealing - Installation Of Accessories (GROUP 80, NO. 203)
- Rear Side Window Leakage - Reseal (GROUP 84, NO. 108)
- Corrosion Protection Repairs/Rustproofing Products (GROUP 80, NO. 108)
- Paint Codes Cross Reference (GROUP 80, NO. 104)
- Passive Restraints
- Procedures
- Data Requests From Lea (Police) And/Or Customers (TJ 28941.5.0)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- High Voltage (HV) Module Balancer Cart (ST-251)
- VIDA Updated Graphical Plotter Functionality Applications - VIDA (SJ1000785)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Newsletter 105: Mandatory Tools (ST-237)
- Recall Compliance Clearance Letter Requests (SMB00-440)
- GDPR - Information Notice (SPJ34864.2.0)
- Rear Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- New Bushing Press Tools/Supplier Information (GROUP 00, NO. 96)
- Replacing Trailing Arm Bushing (GROUP 65, NO. 203)
- Rear SUSP Spring Noise - Remove Excess Undercoating (GROUP 77, NO. 103)
- Steering Wheel Vibration - Control Arm Rear Bushing (GROUP 77, NO. 102)
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Digital Battery Analyzer (STB 111)
- Battery Charging Voltage (GROUP 31, NO. 102)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- D24/D24T Injection Pump Shaft Seal R & R (GROUP 23, NO. 30)
- D24 Engine - Cold Start Device/Idle Speed Adjustment (GROUP 23, NO. 2)
- D24/D24T Engine P20 - Acceleration Test (GROUP 23, NO. 128)
- Fuel Pump Noise - Pressure Damper (GROUP 23, NO. 130)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- 2.3L Eng Noise/Lack Of Power - Revised Fuel Pump (GROUP 23, NO. 132)
- Steering Column
- Interior Seat Protection Kit (SMB85-002)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Bleeding Power Steering Racks - New Procedure (GROUP 64, NO. 119)
- New Torque-Limited Steering Column R & R (GROUP 64, NO. 40)
- Rear SUSP Spring Noise - Remove Excess Undercoating (GROUP 77, NO. 103)
- Steering Wheel Vibration - Control Arm Rear Bushing (GROUP 77, NO. 102)
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Control Module Swapping (TJ 31946.1.2)
- VCT 2000 (9511500 And 9511540) And Cable 9511535 Troubleshooting, Firmware Upgrade, VCT 2000 Recovery (30-05)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- Engine Management Systems And Control Modules (GROUP 28, NO. 206)
- New EPROM Kit - Service Manual Revision (GROUP 28, NO. 920)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 213)
- Use Of Electrical Surge Arrestors When Arc Welding (GROUP 81, NO. 209)
- New Camshaft/Intermediate Shaft Seal & Install Tool (GROUP 21, NO. 121)
- Ignition System Replacement (GROUP 37, NO. 11)
- New EZ-116K Impulse Sender/Specification (GROUP 28, NO. 104)
- 2.3L Eng Exchange Fuel Injection Control Unit (GROUP 23, NO. 138)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- 2.3/2.8L Eng Checking Constant Idle Stabilizer Valve (GROUP 23, NO. 710)
- 2.1/2.3/2.7/2.8 L Eng Revised Carbon Filter (GROUP 23, NO. 207)
- Poor DRIVEABILITY - Intake Valve Carbon Buildup (GROUP 00, NO. 101)
- 2.3L Eng Cold Start Stall Under Load - New Ecu (GROUP 23, NO. 204)
- Rough/Unstable Idle - New Crankcase Ventilation Hose (GROUP 25, NO. 112)
- Asbestos-Free Valve Cover Gasket Replacement (GROUP 21, NO. 13+70)
- 2.3L Eng Unstable Idle - Cis Air Valve/Idle Adj. (GROUP 23, NO. 131)
- B23F/B230F Eng Air Hose Leak - Clamp Cable Harness (GROUP 37, NO. 23)
- D24/D24T Injection Pump Shaft Seal R & R (GROUP 23, NO. 30)
- D24 Engine - Cold Start Device/Idle Speed Adjustment (GROUP 23, NO. 2)
- D24 Engine Head Gasket Revised (GROUP 21, NO. 68)
- D24/D24T Engine P20 - Acceleration Test (GROUP 23, NO. 128)
- Gasoline Eng P20 - New Fuel Pump Wiring Harness (GROUP 23, NO. 121)
- 2.3L Eng Noise/Lack Of Power - Revised Fuel Pump (GROUP 23, NO. 132)
- EZ117/118K Ignition Diagnosis (GROUP 34, NO. 4)
- Transfer Case
- Transmission Control Systems
- Wheel Alignment
- Wheels & Tire System
- Window Motors & Regulators
- Windshield Cleaning (SMB00-444)
- Windshield POWERCURE Dispenser And Adhesive (SMB84-001)
- Windshield Replacement With PUR Bonded Windshield (GROUP 84, NO. 204)
- Power Antenna Malfunction (GROUP 39, NO. 212/932)
- Water Leak At Sunroof - Repair (GROUP 83, NO. 203)
- Sunroof Weatherstrip, Replacement (GROUP 83, NO. 202)
- Water Sealing - Installation Of Accessories (GROUP 80, NO. 203)
- Leaking Sunroof - Modify And Tape Guide Rail Mount (GROUP 83, NO. 201)
- New Door Arch Weatherstrip To Decrease Wind Noise (GROUP 84, NO. 26)
- New Tailgate Weatherstrip/Side Rear Window Seal (GROUP 84, NO. 25)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)