Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Control Module Swapping (TJ 31946.1.2)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- Use Of Electrical Surge Arresters When Arc Welding (GROUP 81, NO. 913)
- Tool For Tightening Fuel Tank Sending Unit Nut (GROUP 23, NO. 720)
- Wrench For Plastic Fuel Level Sender Nut R & I (STB NO. 54)
- Air Bag, SRS
- R10058 Driver Airbag Returns - Shipping Instruction (PB88-010)
- Used Airbag Return/Disposal Pilot Program (SMB88-026)
- Extended Service Life For Airbags (SRS) (GROUP 88, NO. 0002)
- Modifying Airbag Sensor & New Trouble Codes (GROUP 88, NO. 911)
- SRS Test Tools - New Tool Info/Ordering Information (GROUP 00, NO. 38)
- Service Manual Correction - SRS Wiring Text (GROUP 88, NO. 105)
- New SRS Crash Sensor Installation (GROUP 88, NO. 705)
- Modified Knee Bolster Member (SRS Applied Models) (GROUP 88, NO. 706)
- Crash Sensor Replacement (GROUP 88, NO. 2)
- Electrical Fault Tracing - Air Bag Disable Caution (GROUP 30, NO. 101)
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Automatic Transmission Cooler/Lines Flushing (43-56)
- Automatic Transmission Diagnostic Sheet (43-08)
- Transmission And AWD Lubricants (40-04)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Take Off VIB.'S - Center Support Bearing Position (GROUP 45, NO. 102)
- ATF Filter Cleaning/Insp Deleted At Service Interval (GROUP 17, NO. 106)
- 4HP22/Aw70/Aw71 Trans Overdrive Reconditioning (GROUP 43, NO. 14)
- Automatic Transmission Fluid Application (GROUP 43, NO. 112)
- Reseal Speedo Cable After Every Repair (GROUP 38, NO. 702)
- Fuel Injector Maintenance Cleaning (GROUP 23, NO. 129)
- Auxiliary Emission Control Systems
- Oxygen Sensor Thread Repair Method (TJ 35818.1.1)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- Fault Tracing Of Electronic Management Systems (GROUP 28, NO. 914)
- Use Of Electrical Surge Arresters When Arc Welding (GROUP 81, NO. 913)
- Measurement Of Voltage Drop Across Ground Connection (GROUP 37, NO. 909)
- 2.3L Eng Exchange Fuel Injection Control Unit (GROUP 23, NO. 138)
- Axle Shafts
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Front Wheel Hub Assembly Checking/Replacing (GROUP 77, NO. 107)
- Take Off VIB.'S - Center Support Bearing Position (GROUP 45, NO. 102)
- Steering Wheel Noise When Braking - New Hub & Brake (GROUP 51, NO. 111)
- Driveshaft Flange Torque Specifications (GROUP 45, NO. 2)
- New Front Wheel Hub Replacement (GROUP 61, NO. 5)
- Body Interior
- Brakes Control Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 935)
- Installation Of Cooling Thermostat - Procedure (GROUP 26, NO. 204/910)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- 2.3/2.4/2.8L Eng Noise From Front - Aux Cooling Fan (GROUP 26, NO. 118)
- Water Pump Inspection (GROUP 26, NO. 31)
- Oil Leak At Rear Main Bearing - Repair Process (GROUP 21, NO. 5)
- Replace Fuel Tank Pump In Car (GROUP 23, NO. 42)
- Differentials & Drive Axles
- Transmission And AWD Lubricants (40-04)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Replacement Of Upper Bushing In DIFERENTIAL Housing (GROUP 65, NO. 701)
- Take Off VIB.'S - Center Support Bearing Position (GROUP 45, NO. 102)
- 4HP22/Aw70/Aw71 Trans Overdrive Reconditioning (GROUP 43, NO. 14)
- Driveshaft Flange Torque Specifications (GROUP 45, NO. 2)
- VOLVO Special Tools (GROUP 00, NO. 34)
- Differential Housing Bushing Mount Verification (GROUP 46, NO. 1)
- Fuel Injector Maintenance Cleaning (GROUP 23, NO. 129)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Control Module Swapping (TJ 31946.1.2)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- Fault Tracing Of Electronic Management Systems (GROUP 28, NO. 914)
- Use Of Electrical Surge Arresters When Arc Welding (GROUP 81, NO. 913)
- Measurement Of Voltage Drop Across Ground Connection (GROUP 37, NO. 909)
- Tool For Tightening Fuel Tank Sending Unit Nut (GROUP 23, NO. 720)
- Wrench For Plastic Fuel Level Sender Nut R & I (STB NO. 54)
- 2.3L Eng Exchange Fuel Injection Control Unit (GROUP 23, NO. 138)
- Entertainment Systems
- Control Module Swapping (TJ 31946.1.2)
- Stuck CDS In Audio Units (All Models) (TNN 39-51)
- Power Antenna Modification (GROUP 39, NO. 114)
- Radio Fault Tracing P20 & P70 (GROUP 39, NO. 03)
- Radio Interference While Engine Is Running (780) (GROUP 39, NO. 111)
- Power Mirror Adjustment: Popping Noise In Audio SYS. (GROUP 39, NO. 108)
- Exhaust
- Exterior Body Panels
- Use Of Electrical Surge Arresters When Arc Welding (GROUP 81, NO. 913)
- Replacement Parts Modifications For Earlier Models (GROUP 80, NO. 906)
- Replacement Of Fuel Tank Sending Unit - Procedure (GROUP 38, NO. 112)
- Tool For Tightening Fuel Tank Sending Unit Nut (GROUP 23, NO. 720)
- Wrench For Plastic Fuel Level Sender Nut R & I (STB NO. 54)
- New Body Adhesive For Sheet Metal Repairs (GROUP 80, NO. 4)
- Saddle Type Fuel Tank Replacement (GROUP 23, NO. 43)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Recall 82 - Rerouting Of Seat Cable Harnesses (GROUP 85, NO. 11)
- Recall 82 - Rerouting Of Seat Cable Harnesses (GROUP 85, NO. 82)
- Use Of Electrical Surge Arresters When Arc Welding (GROUP 81, NO. 913)
- New Sealed Crimping Sleeve For Wiring Connections (GROUP 37, NO. 701)
- Service Manual Correction - SRS Wiring Text (GROUP 88, NO. 105)
- Sealing Of Wire Splices With Shrink Sleeve (GROUP 37, NO. 201)
- Gauges & Instrument Panels
- Odometer Replacement - Information Sticker (GROUP 38, NO. 114)
- Rear Axle Toothed Wheel/Inductive Pickup Clearance (GROUP 46, NO. 103)
- Tool For Tightening Fuel Tank Sending Unit Nut (GROUP 23, NO. 720)
- Wrench For Plastic Fuel Level Sender Nut R & I (STB NO. 54)
- Prevent Malfunctions Seal Electric Speedo Connector (GROUP 37, NO. 4)
- Replacing Fuel Tank Sender Info (GROUP 38, NO. 6)
- Hazardous Waste Material
- Headlights
- Hoist/Jack
- HVAC Control Systems
- Retailer Technical Journal 19292 Climate Control System, Cleaning (TJ 19292)
- Odor From Evaporator, Install Blower Fan Module (GROUP 87, NO. 955)
- New A/C Compressor Tools Descriptions (GROUP 00, NO. 103)
- Conversion Of A/C System From R12 To R134A (GROUP 87, NO. 936)
- Evaporator Odor - Install Blower Fan Control Module (GROUP 87, NO. 942)
- Evaporator Odor - Treatment (GROUP 87, NO. 948)
- Replacement Of Condenser/Pressure Pipe In A/C System (GROUP 87, NO. 941)
- Exhaust Gas Entry: Climate Control Modification (GROUP 87, NO. 940)
- False Indication Of Leakage - A/C High Pressure Hose (GROUP 87, NO. 938)
- Replacement Of Blower Motor - New Motor Kit (GROUP 87, NO. 930)
- New Fan Housing Modification For Early Blower Motor (GROUP 87, NO. 729)
- ECC Control Panel Modification To Fit Earlier Models (GROUP 87, NO. 723)
- 2.3/2.8L Eng A/C Hose Chafing Protection (GROUP 87, NO. 121)
- Center Air Vent Noise - Vane Repair (GROUP 87, NO. 710)
- A/C Drain Hose Installation (GROUP 87, NO. 712)
- A/C System Disinfectant (GROUP 87, NO. 120)
- Heater Motor Replacement (GROUP 87, NO. 707)
- New A/C Hose O-Rings (GROUP 87, NO. 119)
- Identification
- Vehicle Type And Platform Identification (TJ19245.1.19)
- Expendable Items Parts List (SMB00-108D)
- New Shipping Address And Label (SMB00-012)
- VIN Plate And VIN Specific Labeling Ordering Procedure (SMB89-005)
- VOLVO Model Designations (00-20.A)
- Extended Service Life For Airbags (SRS) (GROUP 88, NO. 0002)
- Odometer Replacement - Information Sticker (GROUP 38, NO. 114)
- Ignition System
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- 2.3/2.8L Eng Checking Constant Idle Stabilizer Valve (GROUP 23, NO. 710)
- Service Manual Correction - Ignition Systems (GROUP 28, NO. 702)
- Poor DRIVEABILITY - Intake Valve Carbon Buildup (GROUP 00, NO. 101)
- Replace Fuel Tank Pump In Car (GROUP 23, NO. 42)
- EZ117/118K Ignition Diagnosis (GROUP 34, NO. 4)
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Oil Consumption Test (TJ 35526.1.6)
- Expendable Items Parts List (SMB00-108D)
- Engine Oil Consumption Test FAQ (SMB22-006)
- Recommended Engine Oils (GROUP 22, NO. 3)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 935)
- Identification Of Abnormal Oil Consumption (GROUP 22, NO. 107)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Oil Viscosity - When Enough Is Enough (GROUP 17, NO. 4)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- Fuel Injector Maintenance Cleaning (GROUP 23, NO. 129)
- Oil Leak At Rear Main Bearing - Repair Process (GROUP 21, NO. 5)
- Replace Fuel Tank Pump In Car (GROUP 23, NO. 42)
- Manual Steering
- Manual Trans
- Transmission And AWD Lubricants (40-04)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Take Off VIB.'S - Center Support Bearing Position (GROUP 45, NO. 102)
- 4HP22/Aw70/Aw71 Trans Overdrive Reconditioning (GROUP 43, NO. 14)
- M46/M47II Trans New First Gear & Bearing (GROUP 43, NO. 113)
- Automatic Transmission Fluid Application (GROUP 43, NO. 112)
- Reseal Speedo Cable After Every Repair (GROUP 38, NO. 702)
- Mechanical
- VOLVO Engine Oil Consumption (SMB22-007)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 935)
- Identification Of Abnormal Oil Consumption (GROUP 22, NO. 107)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- 2.3/2.8L Eng Checking Constant Idle Stabilizer Valve (GROUP 23, NO. 710)
- 2.3L Eng Air Filter Housing Soundproofing (GROUP 25, NO. 702)
- Poor DRIVEABILITY - Intake Valve Carbon Buildup (GROUP 00, NO. 101)
- Valve Cover Oil Seepage - Check Valve Cover Nuts (GROUP 17, NO. 104)
- Cylinder Head Torque Cautions (GROUP 21, NO. 17)
- Oil Leak At Rear Main Bearing - Repair Process (GROUP 21, NO. 5)
- Replace Fuel Tank Pump In Car (GROUP 23, NO. 42)
- Mechanical - Hydraulic
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Parking Brake Cable Bracket - Replacement (GROUP 46, NO. 907)
- Rattling Sound/GIRLING Two-Piston Fr. Brake Caliper (GROUP 51, NO. 907)
- Brake Pad Parts & Specifications (GROUP 51, NO. 701)
- Steering Wheel Noise When Braking - New Hub & Brake (GROUP 51, NO. 111)
- Uneven Brake Wear - New Front Caliper Parts (GROUP 51, NO. 8)
- Fuel Injector Maintenance Cleaning (GROUP 23, NO. 129)
- Modified Rear Brake Caliper/Discs/Pad/Cable Parts (GROUP 51, NO. 10)
- Master Brake Cylinder Update - Removal & Replacement (GROUP 52, NO. 3)
- Memory Modules
- Mirrors
- Paint & Coatings
- Passive Restraints
- Procedures
- Data Requests From Lea (Police) And/Or Customers (TJ 28941.5.0)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- High Voltage (HV) Module Balancer Cart (ST-251)
- VIDA Updated Graphical Plotter Functionality Applications - VIDA (SJ1000785)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Newsletter 105: Mandatory Tools (ST-237)
- Recall Compliance Clearance Letter Requests (SMB00-440)
- GDPR - Information Notice (SPJ34864.2.0)
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Interior Seat Protection Kit (SMB85-002)
- Seat Belt Extender Availability (GROUP 88, NO. 1A)
- Recall 82 - Reroute Of Seat Cable Harness (GROUP 85, NO. 0001)
- Fault Tracing Of Electronic Management Systems (GROUP 28, NO. 914)
- New Heating Pad In Front Seat - Procedure (GROUP 85, NO. 918)
- Power Antenna Malfunction (GROUP 39, NO. 212/932)
- Interior Noises - Noise From Seats & Panels (GROUP 85, NO. 705)
- New Driver's Seat Catch Pins: Minimize Play (GROUP 85, NO. 8)
- Seat Belt RETRACTIION Clip (GROUP 88, NO. 102)
- Starter
- Digital Battery Analyzer (STB 111)
- Battery Charging Voltage (GROUP 31, NO. 102)
- 2.3L Non-Turbo Eng Bat Ground Cable Reroute Info (GROUP 37, NO. 702)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- 2.3L Eng Air Filter Housing Soundproofing (GROUP 25, NO. 702)
- Replace Fuel Tank Pump In Car (GROUP 23, NO. 42)
- Steering Column
- Interior Seat Protection Kit (SMB85-002)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Wheel Angles - New Tolerances (GROUP 61, NO. 902X)
- Steering Wheel Noise When Braking - New Hub & Brake (GROUP 51, NO. 111)
- Bleeding Power Steering Racks - New Procedure (GROUP 64, NO. 119)
- Steering Column Noise - REPL Upper/Lower Spacer Ring (GROUP 64, NO. 702)
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Suspension Control Systems
- System
- Control Module Swapping (TJ 31946.1.2)
- VCT 2000 (9511500 And 9511540) And Cable 9511535 Troubleshooting, Firmware Upgrade, VCT 2000 Recovery (30-05)
- E-Prom Installation Equipment (GROUP 00, NO. 108)
- New Steel Cylinder Head Gasket (GROUP 21, NO. 935)
- Fault Tracing Of Electronic Management Systems (GROUP 28, NO. 914)
- Use Of Electrical Surge Arresters When Arc Welding (GROUP 81, NO. 913)
- Measurement Of Voltage Drop Across Ground Connection (GROUP 37, NO. 909)
- Safety Instructions For FLUOROELASTOMER Seals (GROUP 10, NO. 201/701)
- Tool For Tightening Fuel Tank Sending Unit Nut (GROUP 23, NO. 720)
- Wrench For Plastic Fuel Level Sender Nut R & I (STB NO. 54)
- 2.3L Eng Exchange Fuel Injection Control Unit (GROUP 23, NO. 138)
- Diesel Fuel Quality - New Filter Info (GROUP 23, NO. 136)
- 2.3/2.8L Eng Checking Constant Idle Stabilizer Valve (GROUP 23, NO. 710)
- Service Manual Correction - Ignition Systems (GROUP 28, NO. 702)
- Poor DRIVEABILITY - Intake Valve Carbon Buildup (GROUP 00, NO. 101)
- Replace Fuel Tank Pump In Car (GROUP 23, NO. 42)
- EZ117/118K Ignition Diagnosis (GROUP 34, NO. 4)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- VOLVO Wheel Repair Guidelines (SMB77-008)
- Winter Wheel Applications (PB77-006)
- Tire Rotation (SMB77-007)
- Tire Pressures, Requirements And Recommendations (77-18)
- Torque Sleeves For Wheel Lug Nuts (STB NO. 44)
- Front Wheel Hub Assembly Checking/Replacing (GROUP 77, NO. 107)
- Steering Wheel Noise When Braking - New Hub & Brake (GROUP 51, NO. 111)
- New Front Wheel Hub Replacement (GROUP 61, NO. 5)
- Window Motors & Regulators
- Windshield Cleaning (SMB00-444)
- Windshield POWERCURE Dispenser And Adhesive (SMB84-001)
- Recall 82 - Reroute Of Seat Cable Harness (GROUP 85, NO. 0001)
- Fault Tracing Of Electronic Management Systems (GROUP 28, NO. 914)
- Replacement Of "PUR" Bonded Windows (Supplement) (GROUP 84, NO. 908)
- Power Antenna Malfunction (GROUP 39, NO. 212/932)
- Front Window Winder Mechanism - New Sliding Elements (GROUP 83, NO. 706)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Recall 82 - Rerouting Of Seat Cable Harnesses (GROUP 85, NO. 11)
- Recall 82 - Rerouting Of Seat Cable Harnesses (GROUP 85, NO. 82)
- New Sealed Crimping Sleeve For Wiring Connections (GROUP 37, NO. 701)
- Service Manual Correction - SRS Wiring Text (GROUP 88, NO. 105)
- Sealing Of Wire Splices With Shrink Sleeve (GROUP 37, NO. 201)