Transmission - Oil Level Check & Flush Cleaning
- Transmission
- Gearbox, removing
- Notes
- Filling in Diagnostic and Check lists
- Disconnecting the battery lead
- Removing engine compartment components
- Removing the dipstick
- Removing the gear selector cable from the lever and mounting on the gearbox
- Removing the mounting screws from the gearbox/starter motor
- Removing the right screw from the gearbox
- Installing the lifting beam and lifting hook on the engine lifting eyelet
- Removing splash guards
- Removing the screws for the cable conduit and ground lead bracket on the sub-frame
- Removing the nut for the lower ball joint/control arm
- Remove the control arms, track rod and spring strut on both sides
- Removing the screws for the sub-frame support plates (both sides)
- Removing the stub axle from the control arm
- Removing the drive shaft from the stub axle (right-hand side)
- Removing the cap for the drive shaft support bearing
- Removing the drive shaft
- Press up the sub-frame on the right-hand side
- Removing the nuts and screws for the steering gear sub-frame
- Removing the screws for the torque rod from the gearbox
- Removing the exhaust pipe from the turbocharger (TC)
- Removing the front cross member
- Removing the bracket for the cable for the heated oxygen sensor (HO2S) from the sub-frame
- Removing the exhaust pipe mounting in the rear cross member
- Removing the screw for the rear engine pad
- Removing the rear engine mounting
- Preparations for removing the stub axle on the left-hand side
- Removing the left drive shaft from the gearbox
- Lowering the sub-frame
- Removing the lower oil pipe from the gearbox
- Removing the collision protection system over the steering gear
- Lowering the engine and gearbox
- Removing the 6 screws for the torque converter, and the 7 screws for the gearbox/engine
- Preparations when removing gearbox
- Installing the fixture on the mobile jack and gearbox
- Removing all 7 screws for the gearbox/engine
- Removing the gearbox
- Cleaning and checking
- Oil cooler, flush cleaning
- Oil level, checking (AW55-50/51SN; 2004-2007)
- Oil level, checking (B5244T5, M66; 2005-2008)
- Gearbox, removing