Technical Service Bulletins

• A/C Compressor
  • Fluid Flushing Requirements (26-003-07)
  • Accessory Drive Belt Squeaking/Chirping Sound (09-004-04 REV. B)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Front Power Memory, Heated Seats And/Or Adjustable Pedals Performance (08-031-05)
  • Front Power And/Or Memory Seat Inoperative (08-039-05)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
  • Airbag Control Module And/Or Occupant Classification Module Service (08-019-05)
  • MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
  • Inoperative Driver Door Switches (08-038-04)
• Accessory Drive Belts
  • Accessory Drive Splash Shield Damaged And/Or Missing (07-001-05)
  • Accessory Drive Belt Squeaking/Chirping Sound (09-004-04 REV. B)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
  • Safety Systems - Vehicle Modifications/Repair (08-027-04)
  • Front Passenger Airbag Safety Precautions (08-001-04)
• Anti-Theft Systems
  • Powertrain Control Module Initialization (08-030-06 REV.A)
  • Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
• Automatic Trans
  • Fluid Flushing Requirements (26-004-12)
  • Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
  • Fluid Flushing Requirements (26-003-07)
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
  • Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
• Auxiliary Emission Control Systems
  • 1/1 O2 Sensor Usage (08-008-05)
  • Evaporative Systems Service (25-001-04)
  • Flash: Mil Illumination Diagnostic Trouble Code (DTC) P2066 (18-032-04)
• Body Electrical
  • Inoperative Right Front Door Switches (08-021-08)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
  • Inoperative Driver Door Switches (08-038-04)
• Brakes Control Systems
  • Wheel Speed Sensor Service (05-003-07)
  • Airbag Control Module And/Or Occupant Classification Module Service (08-019-05)
  • Safety Systems - Vehicle Modifications/Repair (08-027-04)
• Charging Systems
  • Accessory Drive Belt Squeaking/Chirping Sound (09-004-04 REV. B)
• Collision/Avoidance
  • Customer Would Prefer A Louder Warning Tone From The Park Assist System (08-020-05)
• Communication Devices
  • Radio Communication Equipment Installation Recommendations (08-024-05)
  • UCONNECT Hands Free Phone Inoperative (08-013-05)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
• Differentials & Drive Axles
  • Rear Axle Seal WEEPAGE Diagnosis (03-005-04)
• Engine Control Systems
  • Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
  • Powertrain Control Module Initialization (08-030-06 REV.A)
  • Flash - I/M Testing - Revised Engine Rpm Limits To Perform A Two Speed Idle (TSI) Test (18-010-06)
  • Flash - No Start Or Hard Start (18-004-06 REV. A)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Powertrain Control Module Initialization (08-015-05)
  • 1/1 O2 Sensor Usage (08-008-05)
  • Flash: Mil Illumination Diagnostic Trouble Code (DTC) P2066 (18-032-04)
  • Safety Systems - Vehicle Modifications/Repair (08-027-04)
• Entertainment Systems
  • Radio Speaker Misdiagnosis - Rattle/Buzz Sounds In Door (23-029-07)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
  • Passenger Compartment Floor Water Leak (23-010-04 REV. A)
  • Flash: Mil Illumination Diagnostic Trouble Code (DTC) P2066 (18-032-04)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Enable Daytime Running Lamps (DRL) (08-041-04)
• Frames, Subframes & Crossmembers
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Vehicle Vibration And/Or Shake (12-001-10)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Creaking/Squawking Sound From Front Strut Area (02-004-05)
  • Low Speed Rattle/Clunk Sound From Front Suspension (02-007-04)
  • Suspension/Towing/Lifting Damage (02-004-04)
• Fuel System
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
  • Throttle Body Service (14-002-07)
  • Loose Fuel Cap Message Or Mil Illumination For Diagnostic Trouble Code P0457 - EVAP System - Loose Fuel Cap (14-001-06)
  • Flash: Mil Illumination Diagnostic Trouble Code (DTC) P2066 (18-032-04)
• Gauges & Instrument Panels
  • Dip Or Sag In The Center Of The Instrument Panel (IP) (23-014-05)
  • Real Wood Trim Scratch Repair (23-033-02)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Color And/Or Brightness Difference On Hid Replacement Headlamp Bulbs (08-029-07)
  • Enable Daytime Running Lamps (DRL) (08-041-04)
• Hoist/Jack
  • Suspension/Towing/Lifting Damage (02-004-04)
• HVAC Control Systems
  • HVAC Drain Water (Ac Condensate) Leaks Under Passenger Side Carpet (24-008-02 REV. A)
  • A/C Cooling Coil Odor (24-013-05)
  • Passenger Compartment Floor Water Leak (23-010-04 REV. A)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Low Gloss Interior Trim (23-036-07)
  • Upper Applique Loose Above Left Front Door (23-015-07)
  • HVAC Drain Water (Ac Condensate) Leaks Under Passenger Side Carpet (24-008-02 REV. A)
  • Headliner Gap At Front Door Weatherstrip (23-036-05)
  • Water In Passenger Compartment (23-035-04)
  • Passenger Compartment Floor Water Leak (23-010-04 REV. A)
  • Front Seat Belt Foul Odor (23-026-04 REV. A)
  • Real Wood Trim Scratch Repair (23-033-02)
• Lubrication System
  • Fluid Flushing Requirements (26-004-12)
  • Fluid Flushing Requirements (26-003-07)
  • Gasoline Engine Oil Quality And Viscosity Grades (09-013-04)
• Manual Steering
  • Fluid Flushing Requirements (26-004-12)
  • Revised Power Steering System Bleeding Procedures (19-008-05 REV. A)
  • Power Steering Fluid Contamination (19-010-04)
  • Accessory Drive Belt Squeaking/Chirping Sound (09-004-04 REV. B)
• Manual Trans
  • Real Wood Trim Scratch Repair (23-033-02)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Vehicle Vibration And/Or Shake X26 (10 Years/150,000 Miles Warranty Extension) (13-001-12)
  • Vehicle Vibration And/Or Shake (12-001-10)
  • Fluid Flushing Requirements (26-003-07)
  • Multiple Cylinder Misfire Or Rough Idle (09-010-06)
• Mechanical - Hydraulic
  • Fluid Flushing Requirements (26-004-12)
  • Fluid Flushing Requirements (26-003-07)
  • Front Power Memory, Heated Seats And/Or Adjustable Pedals Performance (08-031-05)
• Mirrors
  • Inoperative Right Front Door Switches (08-021-08)
  • Inoperative Driver Door Switches (08-038-04)
• Paint & Coatings
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
• Passive Restraints
  • Front Seat Belt Foul Odor (23-026-04 REV. A)
  • Safety Systems - Vehicle Modifications/Repair (08-027-04)
  • Front Passenger Airbag Safety Precautions (08-001-04)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Suspension/Towing/Lifting Damage (02-004-04)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Schedule
  • Fluid Flushing Requirements (26-004-12)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Inoperative Right Front Door Switches (08-021-08)
  • Front Power Memory, Heated Seats And/Or Adjustable Pedals Performance (08-031-05)
  • Front Power And/Or Memory Seat Inoperative (08-039-05)
  • Airbag Control Module And/Or Occupant Classification Module Service (08-019-05)
  • Inoperative Driver Door Switches (08-038-04)
  • New Heated Seat Control Module Available For Service (08-030-04)
  • Front Seat Belt Foul Odor (23-026-04 REV. A)
  • Front Passenger Airbag Safety Precautions (08-001-04)
• Starter
  • MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
  • Steering Wheel Tilt Mechanism Inoperative (19-001-05)
  • In And Out Movement In Steering Column (19-008-04)
  • Real Wood Trim Scratch Repair (23-033-02)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• System
  • Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
  • Multiple Cylinder Misfire Or Rough Idle (09-010-06)
  • Flash - No Start Or Hard Start (18-004-06 REV. A)
  • Loose Fuel Cap Message Or Mil Illumination For Diagnostic Trouble Code P0457 - EVAP System - Loose Fuel Cap (14-001-06)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
  • Flash: Mil Illumination Diagnostic Trouble Codes (DTC) P0135 - O2 Sensor 1/1 Heater Performance (18-010-05 REV. A)
  • 1/1 O2 Sensor Usage (08-008-05)
  • Flash: Mil Illumination Diagnostic Trouble Code (DTC) P2066 (18-032-04)
• Towing
  • Suspension/Towing/Lifting Damage (02-004-04)
• Transfer Case
  • Power Transfer Unit (PTU) Click/Pop Sound (21-011-04)
• Transmission Control Systems
  • Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Front Hub/Half Shaft Click/Pop Sound (03-002-06)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
  • Tire Pressure Monitor - System Information (22-004-06)
• Window Motors & Regulators
  • Inoperative Right Front Door Switches (08-021-08)
  • Circular/Ring Marks On Glass (23-035-05)
  • Front Door Glass Binds, Sticks, And/Or Will Not Move (23-033-05)
  • Front Door Glass Service Procedure Revision (23-032-05)
  • Inoperative Driver Door Switches (08-038-04)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)