Technical Service Bulletins: Other Variant
WARNING: This page is about the Millenia S, which is a different variant/trim than selected.
- A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- Intermittent A/C Operation (U006/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- A/C O-Ring REPALCEMENT (CAT. U, NO. 95-10)
- A/C O-Ring Replacement Part Numbers (CAT. U, NO. 009/95)
- Accessories & Equipment
- Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Instrument Panel Clatter Noise (S007/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Static On Fm Receiver While Operating Rear Defogger (CAT. T, NO. 95-13)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Fm Radio Static/Buzz Noise When Rear Defroster On (MT 0195-04)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Air Bag, SRS
- Anti-Lock Brakes
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- Instrument Panel Clatter Noise (S007/96)
- Abs Control Units - Part Numbers (MT 1194-04)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Traction Control System - Modifications To System (MT 0395-06)
- TCS Indicator Light Will Not Operate In Cold Weather (MT 0295-01)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- TCS Off On Until Engine Coolant Above 32 Degrees (MT 0294-05)
- Anti-Theft Systems
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Wind Noise Around Doors (S018/98)
- Rear Console Surface Cracked (S013/97)
- Rattle Noise From Rear Seat Back (S005/97)
- Key Replacement Program/Ordering Information (AD001/97)
- Anti-Theft Alarm Malfunctions (T019/96)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Door Lock Switch Letters Rub Off (MT 0596-04)
- Door Trim Removal/Installation - Manual Incorrect (S017/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Check Engine Light On - Code P1540 (MT 0995-07)
- Front Door Trim Panel Removal Precautions (MT 06-09)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- New Keyless Entry - Battery Replacement Precautions (MT 07-05)
- Poor A/T Performance - Check Aftermarket Alarm (MT 05-04)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Front Door Weatherstrip Out Of Position - Repair (CAT. S, NO. 018/95)
- Front Door Weatherstrip Out Of Position (CANADIAN) (CAT. S, NO. 95-20)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Keyless Entry System Malfunction - Modified Kit (CAT. T, NO. 009/95)
- Keyless Entry Transmitter Battery Replacement (MT 0595-05)
- Keyless Entry Transmitters - Program All Together (MT 0494-04)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- Keyless Entry System - Changes In System (MT 0395-05)
- Removal Of Door Panels - Caution When Removing (MT 0395-04)
- After Market Alarm - Transmission Shifting Problems (MT 0195-07)
- Cup Holder Moves Roughly During Operation (CANADIAN) (CAT. S, NO. 95-01)
- Key Replacement Program (CAT. AD, NO. 003/95)
- Difficult To Move Cup Holder - Replace Cup Holder (CAT. S, NO. 039/94)
- Fuse Box Cover Missing During PDI - Inside Glove Box (MT 1094-02)
- Front Door Trim Panel Removal - Cautions (MT 0994-05)
- Keyless Entry System - Operation Overview (MT 0694-02)
- Key Replacement Program (CAT. AD, NO. 001/94)
- Automatic Trans
- ATF Leak / Abnormal Shifting / Shift Shock - Reseal (K013/98)
- Service Part Availability Auto Transaxle Bushing (K004/98)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- A/T Oil Cooler Flushing Equipment Guideline (CAT. J, NO. 96-01)
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- Automatic Transmission Repair Policy (CAT. K, NO. 002/95)
- A/T Throttle Cable Adjustment (MT 05-06)
- Harsh 1-2 & 2-3 Shift - Brake Band Adjustment (MT 05-14)
- A/T Fluid - Check Level At Every Service (MT 0195-13)
- Automatic Transmission Throttle Cable Adjustment (MT 0195-12)
- MILLENIA Design Statement (MT 1194-05)
- Automatic Transmission Diagnostic Procedures (CAT. K, NO. 002/94)
- Harsh Shift Feel 2.5 Liter W/GF4A-El (MT 0694-08)
- Auxiliary Emission Control Systems
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- PCV SYS. Modification At Partial Engine Replacement (CAT. B, NO. 004/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Supplemental Diagnostic Procedures For Mil ILLUM. (F013/97)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Fuel Vapor Valve - Correct Installation (MT 0596-01)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
- Announcement Os SST Update Program #001 (CAT. ST, NO. 001/94)
- DRIVEABILITY Concerns - Check Electrical Connections (MT 0694-03)
- O2 Sensor Heater Codes Table (MT 0594-01)
- Pcm Code P1000 - Code Explanation/Not A Trouble Code (MT 0594-02)
- Pcm Code P1000 - Code Explanation/Not A Trouble Code (MT 0294-03)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Blower Motor Inoperative/Fan Speed Incorrect (T002/97)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Check Engine Light On - Code P1540 (MT 0995-07)
- NGS System Message - Data Link Error (MT 06-02)
- Information Display Hard To Read (CANADIAN) (CAT. T, NO. 95-08)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Rear Defroster - Activation/Deactivation Information (MT 0294-02)
- Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Instrument Panel Clatter Noise (S007/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Abs Control Units - Part Numbers (MT 1194-04)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- TCS Indicator Light Will Not Operate In Cold Weather (MT 0295-01)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- Inspection Procedure - Water Pump Leaks (01-016/00)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Oil Leaking From Under The Timing Belt Cover (D001/96)
- Front Engine Oil Leak Under Timing Belt Cover (MT 0596-07)
- Valve Seal Identification (CAT. B, NO. 009/94)
- Valve Seal Identification (CANADIAN) (CAT. B, NO. 95-01)
- Propylene Glycol Based Coolant: Recommendations (CAT. E, NO. 001/94)
- Cruise Control Systems
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Check Engine Light On - Code P1540 (MT 0995-07)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Cruise Control Surging: Replace Cruise Control Unit (CAT. T, NO. 006/94)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Supplemental Diagnostic Procedures For Mil ILLUM. (F013/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
- Announcement Os SST Update Program #001 (CAT. ST, NO. 001/94)
- DRIVEABILITY Concerns - Check Electrical Connections (MT 0694-03)
- O2 Sensor Heater Codes Table (MT 0594-01)
- Pcm Code P1000 - Code Explanation/Not A Trouble Code (MT 0594-02)
- Pcm Code P1000 - Code Explanation/Not A Trouble Code (MT 0294-03)
- Entertainment Systems
- Radio Unlocking Codes (MT-002/22)
- Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
- ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
- Am Radio Noise (T011/96)
- Static On Fm Radio When Rear Defogger Is On (CAT. T, NO. 014/95)
- Static On Fm Receiver While Operating Rear Defogger (CAT. T, NO. 95-13)
- Buzzing In Fm Radio - Inspect Rear Window Defogger (MT 05-03)
- Cd Pause Function - Owner's Manual Correction (MT 05-10)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Cd Pause Function - Owner's Manual Incorrect (MT 0494-02)
- Exchange Cd Changer - Information (MT 0495-13)
- Fm Radio Static/Buzz Noise When Rear Defroster On (MT 0195-04)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Cd Player Random Feature - Owner's Manual Incorrect (MT 0694-07)
- Audio Blank/Skip Function (T003/94)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Exhaust
- Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Rear Body Creaks Driving Slowly/Turning (MT 1395-04)
- Creaking/Knocking Noise From Rear Of Vehicle- Braces (S014/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Rear Seat Back Rattle - Replace Seat Back Bushing (CAT. S, NO. 95-30)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Rattling Noise From Fuel Tank (CANADIAN) (CAT. S, NO. 95-13)
- Rattling Noise From Fuel Tank: Bend Heat Shield (CAT. S, NO. 011/95)
- Clicking/Thump Noise At Drivers Side Floor - Repair (NT 0495-12)
- Snap Noise Around "A" Pillar (CANADIAN) (CAT. S, NO. 95-04)
- Snap Noise Around "A" Pillar - Dashboard Screw (CAT. S, NO. 002/95)
- MILLENIA Design Statement (MT 1194-05)
- Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Headlight Aiming Service Point (T001/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Check Engine Light On - Code P1540 (MT 0995-07)
- Interior C Pillar Light - New Operation (MT 08-13)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Interior "C" Pillar Lights Operation Information (MT 0295-02)
- Replacement Vanity Mirror Bulb Part Number (MT 0894-07)
- Trunk Light Staying On - Adjust Terminal (CAT. T, NO. 002/94)
- Illuminated Entry System - Wiring Reference Update (MT 0694-06)
- Trunk Light Always On - Dead Battery (MT 0394-03)
- Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Rear Bumper Installation Method (S042/96)
- Rear Body Creaks Driving Slowly/Turning (MT 1395-04)
- Creaking/Knocking Noise From Rear Of Vehicle- Braces (S014/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Rear Seat Back Rattle - Replace Seat Back Bushing (CAT. S, NO. 95-30)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Rattling Noise From Fuel Tank: Bend Heat Shield (CAT. S, NO. 011/95)
- Clicking/Thump Noise At Drivers Side Floor - Repair (NT 0495-12)
- Snap Noise Around "A" Pillar (CANADIAN) (CAT. S, NO. 95-04)
- Snap Noise Around "A" Pillar - Dashboard Screw (CAT. S, NO. 002/95)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
- MILLENIA Design Statement (MT 1194-05)
- License Plate Installation (MT 1094-11)
- Installation Of Tie-Down Hole Plugs During PDI (CAT. AD, NO. 006/94)
- Front Suspension
- Creak/Squeak Noise From Rear Suspension (02-002/01)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Noise From Front And Rear Stabilizer Control Links (R003/96)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Fuel System
- Multiple Models - Fuel Injector(S) Replacement Guidelines (01-013/02)
- Multiple Models - Fuel Pump Assembly And Related Component Replacement Guidelines (01-006/02)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Clicking/Thump Noise At Drivers Side Floor - Repair (NT 0495-12)
- Fuses & Circuit Breakers
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Spare Fuse Location - Fill Receptacle 25 (T003/97)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Interior C Pillar Light - New Operation (MT 08-13)
- Fuse Box Cover Installation (CANADIAN) (CAT. A, NO. 95-01)
- Fuse Box Cover Installation - Information (CAT. AD, NO. 010/94)
- Spare Fuse Location: Information (CAT. T, NO. 004/94)
- DRIVEABILITY Concerns - Check Electrical Connections (MT 0694-03)
- O2 Sensor Heater Codes Table (MT 0594-01)
- Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Tach Needle Stuck On Wrong Side Of Stopper Pin (T012/97)
- Center Panel Service Parts Availability (S010/98)
- Rear Console Surface Cracked (S013/97)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Glove Box Lid Does Not Fit Flush With Dash Board (S041/96 REV.)
- Rear Body Creaks Driving Slowly/Turning (MT 1395-04)
- Heater Control Auto Knob Removal (S004/96)
- Instrument Panel Clatter Noise (S007/96)
- Rear Seat Back Rattle - Replace Seat Back Bushing (CAT. S, NO. 95-30)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Information Display Hard To Read (CANADIAN) (CAT. T, NO. 95-08)
- Information Display Hard To Read With HEADLITES "On" (CAT. T, NO. 006/95)
- A/T Position Indicator Light Failure (CANADIAN) (CAT. T, NO. 95-02)
- A/T Position Indicator Light Failure - Replace Case (CAT. T, NO. 001/95)
- Cup Holder Moves Roughly During Operation (CANADIAN) (CAT. S, NO. 95-01)
- Difficult To Move Cup Holder - Replace Cup Holder (CAT. S, NO. 039/94)
- Dashboard - Snapping Noise (MT 1194-06)
- MILLENIA Design Statement (MT 1194-05)
- Fuse Box Cover Missing During PDI - Inside Glove Box (MT 1094-02)
- Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Check Engine Light On - Code P1540 (MT 0995-07)
- Interior C Pillar Light - New Operation (MT 08-13)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Interior "C" Pillar Lights Operation Information (MT 0295-02)
- Replacement Vanity Mirror Bulb Part Number (MT 0894-07)
- Trunk Light Staying On - Adjust Terminal (CAT. T, NO. 002/94)
- Illuminated Entry System - Wiring Reference Update (MT 0694-06)
- Trunk Light Always On - Dead Battery (MT 0394-03)
- Heated Glass/Defoggers
- Hood Material Changed From Aluminum To Steel (S047/96)
- Static On Fm Receiver While Operating Rear Defogger (CAT. T, NO. 95-13)
- Fm Radio Static/Buzz Noise When Rear Defroster On (MT 0195-04)
- Rear Defroster - Activation/Deactivation Information (MT 0294-02)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- HVAC Control Systems
- A/C Odor & Blower Noise Due To Foreign Substance (U011/97)
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- Blower Motor Inoperative/Fan Speed Incorrect (T002/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- Intermittent A/C Operation (U006/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Heater Control Auto Knob Removal (S004/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- Side Vent Louver Bezel Looseness (MT 1195-02)
- A/C O-Ring REPALCEMENT (CAT. U, NO. 95-10)
- A/C O-Ring Replacement Part Numbers (CAT. U, NO. 009/95)
- A/C Evaporator Freezing - Reposition Temp Sensor (CAT. U, NO. 006/95)
- Receiver Drier Replacement Criteria (CANADIAN) (CAT. U, NO. 95-02)
- Receiver Drier Replacement Criteria - Information (CAT. U, NO. 001/95)
- A/C Evaporator Freezing (CANADIAN) (CAT. U, NO. 95-01)
- Evaporator FREZES - REPOSTION Temperature Sensor (MT 0894-09)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Check Engine Light On - Code P1540 (MT 0995-07)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Information Display Hard To Read (CANADIAN) (CAT. T, NO. 95-08)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Interior/Exterior Trim
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Leather Seat Trim Availability - Smooth Grain (S006/97)
- Glove Box Lid Does Not Fit Flush With Dash Board (S041/96 REV.)
- Rear Body Creaks Driving Slowly/Turning (MT 1395-04)
- Seat Back Panel Attachment Information (MT 1295-01)
- Unable OT Operate Ventilator/Or Loose Grill (S018/96)
- Center SUNVISOR Holder Cracked - Replace (S015/96)
- Heater Control Auto Knob Removal (S004/96)
- Instrument Panel Clatter Noise (S007/96)
- Rattle Noise From Rear Package Tray (S012/96)
- Rear Seat Back Rattle - Replace Seat Back Bushing (CAT. S, NO. 95-30)
- Front Door Trim Panel Removal Precautions (MT 06-09)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Front Door Weatherstrip Out Of Position - Repair (CAT. S, NO. 018/95)
- Front Door Weatherstrip Out Of Position (CANADIAN) (CAT. S, NO. 95-20)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- Removal Of Door Panels - Caution When Removing (MT 0395-04)
- Snap Noise Around "A" Pillar - Dashboard Screw (CAT. S, NO. 002/95)
- Scratched Or Peeling B-Pillar Trim (S003/96)
- Dashboard - Snapping Noise (MT 1194-06)
- MILLENIA Design Statement (MT 1194-05)
- Pre-Delivery Inspection Items (CAT. AD, NO. 008/94)
- Front Door Trim Panel Removal - Cautions (MT 0994-05)
- Assist Handle Cap Coming Off: New Cap And Spacer (CAT. S, NO. 027/94)
- Replacement Vanity Mirror Bulb Part Number (MT 0894-07)
- Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Modified Interior Dome Light Bulb Application (MT 0897-05)
- Interior C Pillar Light - New Operation (MT 08-13)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Interior "C" Pillar Lights Operation Information (MT 0295-02)
- Replacement Vanity Mirror Bulb Part Number (MT 0894-07)
- Trunk Light Staying On - Adjust Terminal (CAT. T, NO. 002/94)
- Illuminated Entry System - Wiring Reference Update (MT 0694-06)
- Trunk Light Always On - Dead Battery (MT 0394-03)
- Lubrication System
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Oil Leaking From Under The Timing Belt Cover (D001/96)
- Front Engine Oil Leak Under Timing Belt Cover (MT 0596-07)
- Valve Seal Identification (CAT. B, NO. 009/94)
- Valve Seal Identification (CANADIAN) (CAT. B, NO. 95-01)
- Winter Engine Oil Viscosity Chart (MT 0195-11)
- Manual Steering
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 1995-2002 MILLENIA S - Camshaft Installation Information (01-016/02)
- Piston Standardization Left & Right Bank REPLACEMANT (CAT. 01, NO. 015/99)
- Camshaft Friction Gear Noise - Modified REPL Process (B005/98)
- Smell/Misfire/Oil Consumption - Valve Cover Oil Leak (B007/97)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Tapping Noise When Engine Is Cold (B001/97)
- Oil Leaking From Under The Timing Belt Cover (D001/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Front Engine Oil Leak Under Timing Belt Cover (MT 0596-07)
- Cylinder Head Bolt Change V-6 Engine Only (B002/96)
- No. 1 Engine Mount Modification (B001/96)
- Cam Gear - Timing Mark Identification (MT 05-13)
- Cylinder Heads Not Interchangeable (MT 1095-05)
- Camshaft Friction Gear Noise (CANADIAN) (CAT. B, NO. 95-05)
- Clicking Noise From Camshaft Friction Gear - Repair (MT 0495-10)
- HLA Noise After Long Storage (CANADIAN) (CAT. B, NO. 95-04)
- Hydraulic Lash Adjuster Noise After Long Storage (CAT. B, NO. 005/95)
- Damage To Drive Belt Auto Tension - New TENSIONER (CAT. B, NO. 002/95)
- Valve Seal Identification (CAT. B, NO. 009/94)
- Knock Sensor Cover Eliminated (MT 06-05)
- Valve Seal Identification (CANADIAN) (CAT. B, NO. 95-01)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
- Valve Timing - Cam Gear Timing Marks (MT 0694-01)
- Mechanical - Hydraulic
- Brake Drum/Rotor Resurfacing Machinery Selection (MT 0897-06)
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Caliper Bolt Corrosion - Clean & Seal (MT 0995-11)
- Front Wheel Clicking Noise (MT 08-11)
- Brake Judder Repair (CANADIAN) (CAT. P, NO. 95-02)
- Vibration/Pulsation While Braking - Procedure (CAT. P, NO. 006/94)
- Front Wheel - Clicking Sound (MT 1094-01)
- Click Noise Front - Sand Disc And Wheel Mount Area (MT 0694-04)
- Brake Line Clip - Do Not Modify Line/Remove Clip (MT 0294-01)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
- Memory Modules
- Mirrors
- Rear View Mirror Loose - New Set Screw/Mirror (S002/98)
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Power Door Lock Switch Lettering Rubs Off/Fades (S026/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Check Engine Light On - Code P1540 (MT 0995-07)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Door Mirror Edge Black Grainy Trim - Mirrors Design (MT 0294-04)
- Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Environmental Fallout Repair Procedure (MT 0797-07)
- Sun Roof Lower Panel Cover Loose (S049/96)
- Seat Back Panel Attachment Information (MT 1295-01)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Paint Codes '95 MIATA & '95 MILLENIA (MT 0695-02)
- Water Soluble Transit Coating Removal Procedures (CAT. S, NO. 017/95)
- Transit Coating Removal Exceeding 90 Days (CANADIAN) (CAT. S, NO. 95-17)
- Paint Codes Table (MT 0494-05)
- Transit Coating Removal - Damage Information (MT 0295-06)
- Paint Repair - Fading & Swirl/Wheel Marks (MT 0195-09)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
- Paint Damage - Iron Particles / Industrial Fallout / Acid Rain (09-025/04)
- Procedures
- Rear Suspension
- Creak/Squeak Noise From Rear Suspension (02-002/01)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Noise From Front And Rear Stabilizer Control Links (R003/96)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Seats
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Leather Seat Trim Availability - Smooth Grain (S006/97)
- Rattle Noise From Rear Seat Back (S005/97)
- Rattle Noise From Rear Seat Back (CAT. S, NO. 055/96)
- Seat Belt Extender Description/Ordering Info (CAT. S, NO. 032/96)
- Front Seat Belt Caution Label Pulls Out Of Sleeve (S050/96)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Front Seat Back Clip Availability (S036/96)
- Power Seats Will Not Move Forward (S035/96)
- Rear Body Creaks Driving Slowly/Turning (MT 1395-04)
- Seat Back Panel Attachment Information (MT 1295-01)
- Dirt On Seat Belt And Anchor (CAT. S, NO. 028/96)
- Power Door Lock Switch Lettering Rubs Off/Fades (S026/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Rear Seat Back Rattle - Replace Seat Back Bushing (CAT. S, NO. 95-30)
- Rear Seat Back Rattle - Replace Bushings (CAT. S, NO. 022/95)
- Check Engine Light On - Code P1540 (MT 0995-07)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- MILLENIA Design Statement (MT 1194-05)
- Excess Rear Seat Cushion Material - Tuck It In (MT 0394-04)
- Solar Ventilation
- Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- Grinding Noise During Engine Cranking (G002/97)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Battery Tester Recommendation - New National Account (CAT. ST, NO. 003/95)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- Warranty Bulletin - MAZDA Battery Warranty (CAT. G, NO. 1)
- Camshaft Friction Gear Noise (CANADIAN) (CAT. B, NO. 95-05)
- Clicking Noise From Camshaft Friction Gear - Repair (MT 0495-10)
- Starter Noise - Missing Starter Drive Gear Clip (MT 0394-01)
- Trunk Light Always On - Dead Battery (MT 0394-03)
- Steering Column
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/96)
- Steering Shaft Noise - Click Or Thump (MT 1194-03)
- Hard To Unlock Steering Locking System (CANADIAN) (CAT. N, NO. 95-05)
- Steering Wheel Slightly Off Center (CANADIAN) (CAT. N, NO. 95-04)
- Hard Effort To Unlock Steering Lock System: Realign (CAT. N, NO. 004/95)
- Steering Wheel Slightly Off Center - Procedure (CAT. N, NO. 005/95)
- Auto-Tilt Steering Column Does Not Work (CANADIAN) (CAT. N, NO. 95-03)
- Auto-Tilt Steering Column Does Not Tilt - Switch (CAT. N, NO. 002/95)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Steering Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- NGS System Message - Data Link Error (MT 06-02)
- Auto-Tilt Steering Column Does Not Tilt - Switch (CAT. N, NO. 002/95)
- TCS Off On Until Engine Coolant Above 32 Degrees (MT 0294-05)
- Steering Gear
- Steering Linkage
- Intermediate Shaft Thump/Click Noise (CAT. N, NO. 007/95)
- Front Wheel Clicking Noise (MT 08-11)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Pre-Delivery Inspection Items (CAT. AD, NO. 008/94)
- Sun Roof/T-Top/Convertible Top
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Rear Console Surface Cracked (S013/97)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Rear Body Creaks Driving Slowly/Turning (MT 1395-04)
- Seat Back Panel Attachment Information (MT 1295-01)
- Rear Seat Back Rattle - Replace Seat Back Bushing (CAT. S, NO. 95-30)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- Cup Holder Moves Roughly During Operation (CANADIAN) (CAT. S, NO. 95-01)
- Difficult To Move Cup Holder - Replace Cup Holder (CAT. S, NO. 039/94)
- MILLENIA Design Statement (MT 1194-05)
- Sunroof Frame Cover - Rattles (MT 0894-05)
- Roof Insulator Peeling Off - Replace Insulator (CAT. S, NO. 023/94)
- Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Auto-Tilt Steering Column Does Not Tilt - Switch (CAT. N, NO. 002/95)
- TCS Off On Until Engine Coolant Above 32 Degrees (MT 0294-05)
- System
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Smell/Misfire/Oil Consumption - Valve Cover Oil Leak (B007/97)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- PCV SYS. Modification At Partial Engine Replacement (CAT. B, NO. 004/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Supplemental Diagnostic Procedures For Mil ILLUM. (F013/97)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Fuel Vapor Valve - Correct Installation (MT 0596-01)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- 1995 MILLENIA 2.3L Spark Plugs (CAT. RF, NO. 95-22)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Clicking/Thump Noise At Drivers Side Floor - Repair (NT 0495-12)
- Valve Seal Identification (CAT. B, NO. 009/94)
- Valve Seal Identification (CANADIAN) (CAT. B, NO. 95-01)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
- Announcement Os SST Update Program #001 (CAT. ST, NO. 001/94)
- DRIVEABILITY Concerns - Check Electrical Connections (MT 0694-03)
- O2 Sensor Heater Codes Table (MT 0594-01)
- Pcm Code P1000 - Code Explanation/Not A Trouble Code (MT 0594-02)
- Pcm Code P1000 - Code Explanation/Not A Trouble Code (MT 0294-03)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
- Towing
- Transmission Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Traction Control System - Modifications To System (MT 0395-06)
- After Market Alarm - Transmission Shifting Problems (MT 0195-07)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- MILLENIA Design Statement (MT 1194-05)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Alignment
- Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Wheel Balance Tips For Higher Precision Results (MT 0897-08)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Front Wheel Clicking Noise (MT 08-11)
- Front Wheel - Clicking Sound (MT 1094-01)
- Lug Nut Tightening - Torque Wrench Caution (MT 1094-13)
- Click Noise Front - Sand Disc And Wheel Mount Area (MT 0694-04)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
- Window Motors & Regulators
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Wind Noise Around Doors (S018/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Residue On Glass (MT 0797-02)
- Windshield Fog Or Film (MT 0397-04)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Windshield Stone Chipping Inspection (S037/96)
- Rear Body Creaks Driving Slowly/Turning (MT 1395-04)
- Seat Back Panel Attachment Information (MT 1295-01)
- Power Door Lock Switch Lettering Rubs Off/Fades (S026/96)
- Rear Seat Back Rattle - Replace Seat Back Bushing (CAT. S, NO. 95-30)
- Film Or Residue On Glass - Removal (MT 05-05)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Front Door Weatherstrip Out Of Position - Repair (CAT. S, NO. 018/95)
- Front Door Weatherstrip Out Of Position (CANADIAN) (CAT. S, NO. 95-20)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Cup Holder Moves Roughly During Operation (CANADIAN) (CAT. S, NO. 95-01)
- Film/Residue On Glass - Polish Glass With Compound (MT 0195-10)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Difficult To Move Cup Holder - Replace Cup Holder (CAT. S, NO. 039/94)
- MILLENIA Design Statement (MT 1194-05)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Keyless Entry System Malfunction Near Garage Opener (CAT. T, NO. 95-09)
- DRIVEABILITY Concerns - Check Electrical Connections (MT 0694-03)
- O2 Sensor Heater Codes Table (MT 0594-01)