Symptom Troubleshooting [Engine L5]

• Symptom Troubleshooting Wiring Diagram
• Symptom Diagnostic Index
• Control System Device And Control Relationship Chart
• Quick Diagnostic Chart
• Foreword
• No.1 Melting Of Main Or Other Fuses
• No.2 Mil Illuminates
  • Notes
  • Diagnostic procedure
• No.3 Will Not Crank
  • Notes
  • Diagnostic procedure
• No.4 Hard To Start/Long Crank/Erratic Start/Erratic Crank
  • Notes
  • Diagnostic procedure
• No.5 Engine Stalls-After Start/At Idle
  • Notes
  • Diagnostic procedure
• No.6 Cranks Normally But Will Not Start
  • Notes
  • Diagnostic procedure
• No.7 Slow Return To Idle
  • Notes
  • Diagnostic procedure
• No.8 Engine Runs Rough/Rolling Idle
  • Notes
  • Diagnostic procedure
• No.9 Fast Idle/Runs On
  • Notes
  • Diagnostic procedure
• No.10 Low Idle/Stalls During Deceleration
  • Notes
  • Diagnostic procedure
• No.11 Engine Stalls/Quits, Engine Runs Rough, Misses, Buck/Jerk, Hesitation/Stumble, Surges
  • Notes
  • Diagnostic procedure
    • Overview
    • Notes
    • No.13 Knocking/Pinging-Acceleration/Cruise [L5]
  • No.12 Lack/Loss Of Power-Acceleration/Cruise [L5]
• No.14 Poor Fuel Economy
  • Notes
  • Diagnostic procedure
• No.15 Emission Compliance
  • Notes
  • Diagnostic procedure
• No.16 High Oil Consumption/Leakage
  • Notes
  • Diagnostic procedure
• No.17 Cooling System Concerns-Overheating
  • Notes
  • Diagnostic procedure
• No.18 Cooling System Concerns-Runs Cold
  • Notes
  • Diagnostic procedure
• No.19 Exhaust Smoke
  • Notes
  • Diagnostic procedure
• No.20 Fuel Odor (In Engine Compartment)
  • Notes
  • Diagnostic procedure
• No.21 Engine Noise
  • Notes
  • Diagnostic procedure
  • No.22 Vibration Concerns (Engine) [L5]
• No.23 A/C Does Not Work Sufficiently
  • Notes
  • Diagnostic procedure
  • No.24 A/C Is Always On Or A/C Compressor Runs Continuously [L5]
  • No.25 A/C Is Not Cut Off Under Wide Open Throttle Conditions [L5]
  • No.26 Exhaust Sulphur Smell [L5]
  • No.27 Fuel Refill Concerns [L5]
  • No.28 Fuel Filling Shut Off Concerns [L5]
  • No.29 Spark Plug Condition [L5]
    • Notes
    • Diagnostic procedure
• Intermittent Concern Troubleshooting
  • Vibration Method
    • Notes
    • Inspection Method for Switch Connectors or Wiring Harnesses
    • Inspection Method for Sensor Connectors or Wiring Harnesses
    • Inspection Method for Sensors
    • Inspection Method for Actuators or Relays
  • Water Sprinkling Method
• Engine Control System Operation Inspection
  • Input Signal System Inspection Procedure
    • Notes
    • Finding irregular signals
    • Locating the source of unusual signals
    • Thermistor type (IAT sensor and ECT sensor)
      • Input signal system inspection for thermistor type
      • GND system inspection for thermistor type
  • Main Relay Operation Inspection
  • Intake Manifold Vacuum Inspection
  • Electronic Throttle Control System Inspection
    • Engine coolant temperature compensation inspection
    • Load compensation inspection
    • Throttle position (TP) sweep inspection
  • Variable Intake Air Control Operation Inspection
  • Variable Tumble Control Operation Inspection
  • Fuel Injector Operation Inspection If simulation function of M-MDS is used
  • Fuel Cut Control System Inspection
  • Fuel Pump Operation Inspection
  • Fuel Pump Control System Inspection
  • Spark Test
  • EGR Control System Inspection
  • Purge Control System inspection
  • A/C Cut-off Control System Inspection
  • Cooling Fan Control System Inspection
    • Notes
    • Cooling fan NO.1 and NO.2 do not operate
    • Cooling fan motor NO.1 does not operate
    • Cooling fan motor NO.2 does not operate
  • Variable Valve Timing Control System Operation Inspection When idling cannot be continued
  • Evaporative Emission (EVAP) System Leak Inspection
    • Notes
    • EVAP system leak inspection using the M-MDS
      • EVAP system test out line
      • EVAP system test description
      • EVAP system malfunction judgment
      • Evaporative system test procedure