OEM General Information: General

• How To Use This Manual
  • Maintenance, Repair And Servicing Explanations
  • On-Vehicle Service
  • Service Procedures
  • Definition Of Terms
    • Standard Value
    • Limit
    • Reference Value
    • Danger, Warning, And Caution
    • Tightening Torque Indication
    • Special Tool Note
    • Abbreviations
    • Explanation Of Manual Contents
• Troubleshooting Guidelines
  • Verify The Complaint
  • Determine Possible Causes
  • Find The Symptom
  • Repair The Symptom
  • Verify The Repair
• How To Use Troubleshooting/Inspection Service Points
  • Troubleshooting Contents
    • Notes
    • Standard Flow Of Diagnostic Troubleshooting
      • Notes
      • Diagnostic Method
    • System Operation And Symptom Verification Tests
    • Diagnostic Function
    • Diagnostic Trouble Code Chart
    • Symptom Chart
    • Diagnostic Trouble Code Procedures
    • Symptom Procedures
    • Service Data Reference Table
    • Check At Ecu Terminals
    • Terminal Voltage Checks
    • Terminal Resistance And Continuity Checks
    • Inspection Procedures Using An Oscilloscope
  • Permutation Table In Scan Tool (M.U.T.-IIISE) System Names
  • How To Use The Inspection Procedures
    • Notes
    • Harness Inspection
    • Measures To Take After Replacing The Ecu
  • Connector Measurement Service Points
    • Notes
    • If Inspecting With The Connector Connected Waterproof Connectors
    • If Inspecting With The Connector Connected Ordinary (Non-Waterproof) Connectors
    • If Inspecting With The Connector Disconnected
  • Connector Inspection Service Points
    • Visual Inspection
    • Connector Pin Inspection
    • Connector Engagement Inspection
  • How To Cope With Intermittent Malfunctions
    • Notes
    • To Cope With Intermittent Malfunction; 1. Ask The Customer About The Malfunction
    • Determine The Conditions From The Customer's Responses
    • Use Simulation Test
    • Verify The Intermittent Malfunction Is Eliminated
    • Simulation Tests
  • How To Treat Past Trouble
  • Inspection Service Points For A Blown Fuse
  • Relay Check
    • Notes
    • Relay Check
• Vehicle Identification
  • Vehicle Identification Number Plate
    • Vehicles Identification Number Location
      • Notes
      • Code Chart
    • Vehicle Identification Number List
      • Vehicles For USA
      • Vehicles For CANADA
  • Vehicle Identification Number (Chassis Number)
    • Notes
    • Code Chart
  • Vehicle Information Code Plate
    • Notes
    • Code Chart
  • Certification Label
  • Tire And Loading Information Placard
  • Engine Model Stamping
• General Data And Specifications
  • Vehicles For USA
  • Vehicles For CANADA
• Precautions Before Service
  • About The Description Of The Ignition Switch
  • Power Supply Mode By The Engine Switch Operation
  • Engine Switch Indicator
  • Supplemental Restraint System (SRS)
  • Vehicles With Air Conditioning
  • Scan Tool [Multi Use Tester (M.U.T.-IIISE) Sub Assembly]
    • M.U.T.-IIISE
  • Servicing Electrical System
  • How To Shift Lock Forced Release
  • How To Perform VIN Writing
    • Notes
    • Engine Key Code And VIN Registration Steps For The ECM <Vehicles Without Kos>
    • VIN Registration Steps For The ECM <Vehicles With Kos>
    • VIN Writing Steps For ETACS-Ecu (Immobilizer)
    • VIN Writing Steps For Kos & OSS-Ecu
    • VIN Registration Steps For The ETACS-Ecu (ETACS)
    • VIN Registration Steps For The EPS-Ecu
    • VIN Registration Steps For The SRS-Ecu
  • Engine Idling Learning Procedure
    • Purpose
    • Learning Procedure
    • Initialization Procedure For Throttle Actuator Control Motor
  • Pre-Inspection Condition
  • Precautions For Installation Of On-Vehicle Radio Transmission Equipment
    • Notes
    • Frequency, Output, And Radio Wave Type Of The Radio Transmission Equipment
  • Engine Oils
    • Health Warning
    • Recommended Precautions
  • Form-In-Place Gasket (FIPG)
    • Notes
    • Disassembly
    • Gasket Surface Cleaning
    • Application Procedure
  • Initialization Procedure For Learning Value In DFI And MFI Engine
    • Notes
    • Initialization Procedure
  • Timing Chain Learned Value Reset
    • Notes
    • Initialization Procedure
  • Bolts And Nuts With Stabilizer For Coefficient Of Friction
  • Application Of Anti-Corrosion Agents And Undercoats
  • Vehicle Washing
• Supplemental Restraint System (SRS)
• SRS Service Precautions
• Towing And Hoisting
• Lifting, Jacking Support Location
  • Garage Jack
  • Rigid Racks And A Single-Post Lift Or Double-Post Lift
  • Plate Type Lift
• Customization Function
  • ETACS Customization
  • Combination Meter Special Function
    • Notes
    • Turn-Signal Sound Customization
• Lubrication And Maintenance
  • Notes
  • Maintenance Schedules
  • Severe Service
  • Engine Oil
  • Lubricants And Greases
  • Fuel Usage Statement
  • Gasoline Containing Alcohol
  • Gasoline Containing Methyl Tertiary Butyl Ether (MTBE)
  • Materials Added To Fuel
• Recommended Lubricants And Lubricant Capacities Table
  • Recommended Lubricants
  • Lubricant Capacity Table
  • Lubricant Selection
    • Engine Oil
    • Oil Viscosity
• Scheduled Maintenance Table
  • Selecting The Proper Maintenance Schedule
    • Notes
    • Schedule 1
    • Schedule 2
• Scheduled Maintenance Table
  • Scheduled Maintenance Service For Emission Control And Proper Vehicle Performance
  • General Maintenance Service For Proper Vehicle Performance
  • Scheduled Maintenance Under Severe Usage Conditions
• Maintenance Service
  • Fuel System (Tank, Pipe Line And Connection, And Fuel Tank Filler Tube Cap)
    • Check For Leaks
  • Fuel Hoses
    • Check Condition
  • Air Cleaner Element
    • Replace
  • Evaporative Emission Control System (Except Evaporative Emission Canister)
    • Check For Leaks And Clogging
  • Spark Plugs (Iridium-Tipped Type)
    • Replace
  • Intake And Exhaust Valve Clearance (Inspect And Adjust)
  • Drive Belt (For Generator, A/C Compressor And Water Pump)
    • Check Condition
  • Exhaust System (Connections Portion Of Muffler, Muffler Pipes And Converter Heat Shields)
    • Check And Service As Required
  • Engine Oil
    • Change
  • Engine Oil Filter
    • Replace
  • CVT (Transmission) Fluid
    • Check Fluid Level And Condition
    • Change
  • Transfer Oil
    • Check Oil Level And Condition
    • Change
  • Engine Coolant
    • Change
  • Coolant Hoses (Radiator Hose, Heater Hose)
    • Inspect
  • Disk Brake Pads, Rotors
    • Brake Pad Check
      • <Front>
      • <Rear>
    • Brake Disc Check
      • Brake Disc Thickness Check
      • Brake Disc Thickness Unevenness Check And Correction
      • Brake Disc Run-Out Check And Correction
  • Brake Hoses
    • Check For Deterioration Or Leaks
  • Brake Fluid
    • Change
    • Bleeding Of Brake Pipeline
  • Ball Joint And Steering Linkage Seals
    • Inspect For Grease Leaks And Damage
  • Drive Shaft Boots
    • Inspect For Grease Leaks And Damage
  • Suspension System
    • Inspect For Looseness And Damage
  • Rear Axle Oil
    • Gear Oil Level Check
    • Gear Oil Change
  • Tires
    • Rotate
  • Air Filter
    • Replace
• Main Sealant And Adhesive Table