Technical Service Bulletins

• A/C Compressor
  • A/C End Cover/Valve Plate Leak - Revised Rebuild Kit (24-01-89)
• Anti-Theft Systems
  • Sluggish Right Rear Door Lock - New Lock Motor (08-20-87)
  • Test Procedure For Front Seat Belt Lock Function (23-10-87)
• Automatic Trans
  • Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • A/T Failure - ATF Cooler Flushing Procedure (21-10-89)
  • A413/A470 Harsh/Abrupt Engagement Inti Drive (21-04-88)
  • 2.5/3.0L Buck/Surge Above 35MPH - Lockup Torque CONV (18-13-87)
  • A/T Delayed D Or R Engagement - Separator Plate (21-03-88)
  • AURO Trans High Pullout Effort From Park (21-14-87)
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
• Auxiliary Emission Control Systems
  • Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
  • 2.2L EFI/2.5L EFI/3.0L Eng: Map Sensor Replacement (18-03-90)
  • 2.2/2.5/2.6/3.0L Eng EGR Valve Diagnostic (25-01-89)
  • Erratic Low Idle ANR/Or No Fast Idle With Code 25 (18-18-88)
  • 2.2/2.5L Eng Slow Return To Idle - Logic Module/SMEC (18-11-88)
  • 2.2L Non-Turbo - Erratic Warm Idle With Ac/Defrost (18-09-87 REV. A)
  • Surge/Drop Out Of Cruise Control - Distance Sensor (08-12-87)
• Axle Shafts
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
• Clutch
  • Clutch Growl At Medium/High Speed - Release Lever (06-02-89 REV. A)
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
  • Reverse Clash/Clutch Won't Release - Pressure Plate (06-01-86 REV. A)
• Cooling System (Mechanical)
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • Failed Emissions/Black Smoke/Code 52 - Fuel Injector (18-57-86)
• Cruise Control Systems
  • Surge/Drop Out Of Cruise Control - Distance Sensor (08-12-87)
• Differentials & Drive Axles
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
• Driveshaft & Universal Joints
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
• Engine Control Systems
  • Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
  • 2.2L EFI/2.5L EFI/3.0L Eng: Map Sensor Replacement (18-03-90)
  • Erratic Low Idle ANR/Or No Fast Idle With Code 25 (18-18-88)
  • 2.2/2.5L Eng Slow Return To Idle - Logic Module/SMEC (18-11-88)
  • 2.2L Non-Turbo - Erratic Warm Idle With Ac/Defrost (18-09-87 REV. A)
  • Surge/Drop Out Of Cruise Control - Distance Sensor (08-12-87)
• Exhaust
  • 2.5L Short Deck Service - New Catalytic Converter (09-14-89)
  • 2.2/2.5L Eng Exhaust Chirp/Clunk Noise Or Leak (11-01-88)
• Front Suspension
  • Front Shock Towers Sheet Metal Screws Installation (02-08-92)
• Fuel System
  • Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
• Gauges & Instrument Panels
  • A/C & Heater Control Knob Disengagement - Adhesive (24-01-88)
  • Compass Calibration/Testing/Degaussing Revisions (08-14-87)
• Ignition System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.2L Non-Turbo - Erratic Warm Idle With Ac/Defrost (18-09-87 REV. A)
  • Failed Emissions/Black Smoke/Code 52 - Fuel Injector (18-57-86)
• Locking Hubs
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
• Lubrication System
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • New "SG" Quality Engine Oil (10-51-89)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • Failed Emissions/Black Smoke/Code 52 - Fuel Injector (18-57-86)
• Manual Trans
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
• Mechanical
  • 2.5L Short Deck Service - New Catalytic Converter (09-14-89)
  • New "SG" Quality Engine Oil (10-51-89)
  • 2.2/2.5L Eng Cold Start Rough Idle - Valve Adjusters (18-20-88)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • 2.2/2.5L Timing Belt Skips/No Cold Start - Sealing (09-07-86)
  • Failed Emissions/Black Smoke/Code 52 - Fuel Injector (18-57-86)
• Mechanical - Hydraulic
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
• Mirrors
  • Sluggish Right Rear Door Lock - New Lock Motor (08-20-87)
• Paint & Coatings
  • Off Color Paint - Color Variance Chart Program (23-02-91)
• Rear Suspension
  • Front Shock Towers Sheet Metal Screws Installation (02-08-92)
• Seats
  • Sluggish Right Rear Door Lock - New Lock Motor (08-20-87)
  • Test Procedure For Front Seat Belt Lock Function (23-10-87)
  • New Rear Seat Shoulder Belt Packages/Installation (23-06-87)
• Starter
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
• Steering Gear
  • Steering Gear Retaining Bolt Replacement (13-01-90)
• Steering Linkage
  • Steering Gear Retaining Bolt Replacement (13-01-90)
• System
  • Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
  • Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • 2.2L EFI/2.5L EFI/3.0L Eng: Map Sensor Replacement (18-03-90)
  • 2.2/2.5/2.6/3.0L Eng EGR Valve Diagnostic (25-01-89)
  • 2.2/2.5L Eng Cold Start Rough Idle - Valve Adjusters (18-20-88)
  • Erratic Low Idle ANR/Or No Fast Idle With Code 25 (18-18-88)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • 2.2/2.5L Eng Slow Return To Idle - Logic Module/SMEC (18-11-88)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.2L Non-Turbo - Erratic Warm Idle With Ac/Defrost (18-09-87 REV. A)
  • Surge/Drop Out Of Cruise Control - Distance Sensor (08-12-87)
  • Failed Emissions/Black Smoke/Code 52 - Fuel Injector (18-57-86)
• Transfer Case
  • Low Speed Driveline Shudder - Shaft Bearing Mount (02-07-87)
• Wheels & Tire System
  • Tire Thump/Vibration - Flat-Spotting Diagnosis (22-52-89)
  • Vibration/Shake At 45-65 Mph - Tire RUNOUT/Balance (22-01-87)
  • Tires Rub During Severe Turns/Braking - Normal (22-02-86)
• Window Motors & Regulators
  • Sluggish Right Rear Door Lock - New Lock Motor (08-20-87)