Section 455 (Body Panel System - Body Closures)
WARNING: This page is about a different car, the 2002 Ford Windstar. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description And Operation
- Diagnosis And Testing
- Power Sliding Door
- Notes
- Special Tool(s)
- Principles of Operation
- Power and Ground Requirements
- Power Sliding Door (PSD) Latch Switch
- Latch Release Actuator
- Position Sensor
- Drive Assembly Actuator Clutch
- Drive Assembly Actuator Motor
- Overhead Console On/Off Switch
- Overhead Console Open/Close Switch
- B-Pillar Open/Close Switch
- Remote Keyless Entry Operation
- REM Module Interface
- Power Sliding Door Operation
- Power Sliding Door Module Self-Test
- Reinitialization Procedure
- Inspection and Verification
- LPSDM Diagnostic Trouble Code (DTC) Index
- RPSDM Diagnostic Trouble Code (DTC) Index
- REM Diagnostic Trouble Code (DTC) Index
- Symptom Chart
- Pinpoint Tests
- Pinpoint Test A: No Communication With The Left Power Sliding Door Module
- Pinpoint Test B: No Communication With The Right Power Sliding Door Module
- Pinpoint Test C: No Communication With The Rear Electronics Module
- Pinpoint Test D: DTC B2238 Broken Cable Detected
- Pinpoint Test E: DTC B2270 PSD Exceeded Time Allowed To Cinch Door (Exceeded Time Allowed To Reach Primary Latch Position After Reaching Secondary Latch Position)
- Pinpoint Test F: DTC B2271 PSD Did Not Reach Full Open Position During Self-Test
- Pinpoint Test G: DTC B2363 Position Sensor System Failure
- Pinpoint Test H: DTC B2364 Fuel Filler Door Open Circuit
- Pinpoint Test I: DTC B2365 B-Pillar Power Sliding Door Open/Close Switch Circuit Short To Ground
- Pinpoint Test J: DTC B2366 PSD Open/Close Switch Circuit Short To Ground
- Pinpoint Test K: DTC B2374 PSD Latch Switch Circuit Short To Ground
- Pinpoint Test L: DTC B2483 Enable Signal Open Circuit (Park)
- Pinpoint Test M: DTC B2589 No PSD Latch Switch Detected On Closing And Door Reversed
- Pinpoint Test N: DTC B2591 No PSD Latch Switch Detected On Unlatch
- Pinpoint Test O: DTC B2592 Door Not Pulled To Primary During Power Close And High Duty Cycles
- Pinpoint Test P: DTC B2593 Door Reversed While Closing Due To An Obstacle
- Pinpoint Test Q: DTC B2594 No Movement Detected After An Unlatch During Power Open
- Pinpoint Test R: DTC B2603 PSD Not Fully Closed During Self-Test
- Pinpoint Test S: DTC B2604 PSD On/Off Switch Open Circuit
- Pinpoint Test T: DTC B2605 Disable Signal Open Circuit (VSS > 10 Km/H [6 Mph])
- Pinpoint Test U: The Power Sliding Door Is Inoperative - No DTCS Are Retrieved (Right)
- Pinpoint Test V: The Power Sliding Door Is Inoperative - No DTCS Are Retrieved (Left)
- Pinpoint Test W: The Power Sliding Door Is Inoperative From An Individual Switch- No DTCS Are Retrieved
- Pinpoint Test X: The Power Sliding Door Is Inoperative From The Remote Keyless Entry Transmitter
- Pinpoint Test Y: The Left Power Sliding Door Operates With The Fuel Door Open
- Pinpoint Test Z: The Power Sliding Door Operates From The B-Pillar Switch Or Manual Activation (Power Assist) With The Overhead Console Switch In The Off Position
- Power Sliding Door
- General Procedures
- Removal And Installation
- Fuel Filler Interlock Catch
- Door
- Door - Power Sliding
- Door - Liftgate
- Actuator - Drive Assembly, Left
- Actuator - Drive Assembly, Right
- Actuator - Latch Release
- Sensor - Position, Left
- Sensor - Position, Right
- Switch - PSD Latch
- Switch - Overhead Console
- Switch - B-Pillar
- Switch - Fuel Filler
- Module - LH
- Module - RH